Fluid requirements
full bulletin at NHTSA ↗2012 Volkswagen Routan powertrain problems
moderate 7 complaints filed with NHTSA · avg repair $2,500 · see powertrain across all vehicles →
Complaints
7
Recalls
0
Avg fix
$2,500
When does it fail?
Of the 7 powertrain complaints filed for the 2012 Volkswagen Routan, here's the actual mileage breakdown — failures cluster heaviest at 0-25,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
What stands out
Of the 4 model years of Volkswagen Routan we track for powertrain problems, this one has the fewest owner complaints on file (7).
No new NHTSA powertrain complaint has been filed on this vehicle in over 4 years — the issue may be aging out of the active population.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering powertrain on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Auto Trans fluid requirements.
full bulletin at NHTSA ↗PLATE, TORQUE CONVERTER DRIVE For 3.6L with 62TE NOTE: FOR ALL PROMASTER (VF) 3.6L/62TE EQUIPPED VEHICLES: IF THE TRANSMISSION BRACKET TO THE TRANSMISSION CASE FASTENERS ARE REMOVED DURING SERVICING, THE FASTENERS (Part Number 06511385A$) ARE ONE TIME USEAGE & MUST BE REPLACED & PROPERLY TORQUED TO 105NM Replace the eight bolts (8) 06503465 drive plate to crank shaft and the four TC bolts 06504383 as they have sealants Vehicle miles < 30K: Mandatory replacement of transmission and driveplate Vehicle miles > 30K: Replace driveplate only (shot peened)
full bulletin at NHTSA ↗Transmission Fluid requirements updated to include additional model year applicability.
full bulletin at NHTSA ↗Specific diagnostic check to address DTC U0151, after TIPM component replacement. Part identification, location and ensured installation after rplacing Integrated Power Module.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 4 most recent
The transmission on our 2012 VW Routan has completely failed. The car will not go into gear and left my wife in a position where she was stranded in traffic. We are the original owners of this vehicle and have followed the recommended maintenance schedule. The engine in this vehicle is a Chrysler Pentastar V6. (The vehicle was built as a joint venture between VW and Chrysler) According to…
Tl* the contact owns a 2012 Volkswagen routan. The contact stated that while driving at various speeds, there was a ticking sound coming from the engine. The vehicle was taken to street Volkswagen located at 8707 pilgrim dr, amarillo, tx 79119, who diagnosed that the engine fly-wheel was damaged and needed to be replaced. After replacing the fly-wheel, the failure continued. The dealer later…
Tl* the contact owns a 2012 Volkswagen routan. The contact stated that when the vehicle was shifted into reverse, it jerked and reversed rough without warning. The vehicle was taken to a dealer where it was determined that the vehicle was operating as intended. The vehicle was taken to the dealer on two occasions where the failure was not determined. The manufacturer was not notified of the…
Several times in the last month the car has stopped running without warning. It just shuts off. This has happened in our subdivision travelling at 20mph and most recently on the highway travelling 65mph. The power steering, brakes, everything go dead when the car just turns off and this could cause a serious accident.
Had powertrain trouble with your 2012 Volkswagen Routan?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the powertrain problem on the 2012 Volkswagen Routan?
It's a documented issue but not catastrophic. 7 complaints have been filed. Repairs average $2,500 and most owners catch it before it causes a breakdown.
At what mileage does the powertrain typically fail?
Based on the 7 complaints filed, powertrain issues most often appear around 31,000 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $2,500 for powertrain repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to powertrain?
No active recalls currently cover powertrain issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2012/Volkswagen/Routan.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.