BMW of North America, LLC (BMW NA) is extending the limited warranty for the engine timing chain and oil pump drive chain modules to: 7 years/70,000 miles as determined by the vehicle's original in-service date
full bulletin at NHTSA ↗2014 BMW 528i powertrain problems
moderate Owners of the 2014 BMW 528i have filed 5 NHTSA complaints about the powertrain at roughly $2,500 to repair (U.S. federal records, as of July 2026). Source: NHTSA Office of Defects Investigation. See powertrain across all vehicles →
Complaints
5
Recalls
0
Avg fix
$2,500
| Model year | powertrain complaints |
|---|---|
| 2011 528i | 23 |
| 2012 528i | 22 |
| 2013 528i | 12 |
| 2014 528i (this page) | 5 |
When does it fail?
Of the 5 powertrain complaints filed for the 2014 BMW 528i, here's the actual mileage breakdown — failures cluster heaviest at 50,000-75,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
What stands out
Of the 4 model years of BMW 528i we track for powertrain problems, this one has the fewest owner complaints on file (5).
No new NHTSA powertrain complaint has been filed on this vehicle in over 3 years — the issue may be aging out of the active population.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering powertrain on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
N20 and N26 Differential Pressure Sensor Fault: 195002 Stored in DME: The Service Engine Soon (MIL) light is on with the following differential pressure sensor fault stored: 195002 - Differential pressure sensor, tank vent valve, electrical: Short circuit to ground During engine operation, vibration and movement of the sensor can damage the pin contacts of the harness connector, or cause a break in the wiring.
full bulletin at NHTSA ↗TICKING NOISE WHILE CORNERING WITHOUT THE BRAKES APPLIED: This Service Information Bulletin (Revision 3) replaces SI B34 05 17 dated September 2017. Ticking noise coming from front wheel while cornering without brakes applied noticeable at low speeds. The vehicle must be moving. See attached video V34 01 20 Note: For a similar noise heard when parking with the brakes applied refer to SIB 31 01 12. Microscopic movement of the contact interface between the inner brake disc and the wheel bearing flange on vehicles equipped with lightweight brake discs.
full bulletin at NHTSA ↗TICKING NOISE FROM THE FRONT AXLE WHEN CORNERING: The customer may complain of a metallic ticking noise from the front axle when cornering, maneuvering, parking or pulling away from a parking space.
full bulletin at NHTSA ↗N63, N63TU, S63 and S63TU Engines: Oil Leak from the Rear of the Engine and Transmission Bell Housing. Customer complains that engine oil is leaking from the center of the vehicle. When verified, the engine oil residue can be seen leaking from between the engine and the transmission bell housing.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 3 most recent
I purchased the used BMW from a very reputable dealership May 2021. Last week, I was driving the car and all of the dashboard lights went on suddenly. The car began to buck and I pulled over immediately. I had the car towed to the local BMW dealership. The service department informed me, the serpentine belt broke, wrapped around the crankshaft, and grinded into pieces. The pieced of the belt were…
The Check engine light is displayed, a drivetrain malfunction message is being displayed and the engine's power output has been reduced The issue is diagnosed as turbocharger wastegate valve actuator I would like for BMW to extend the limited warranty for this issue to 2014 BMW 528i
After parking the car for extended time (>7hours), hot weather, starting the car and put in reverse, back out slowly the engine stalls, transmission flips by itself to neutral (n) and a message on screen stating that transmission is not in park, ...., this happened 3 times in the last 2 weeks. Happening earlier but was only shaking when reversing and engine stays on. Now got worse and engine…
Had powertrain trouble with your 2014 BMW 528i?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the powertrain problem on the 2014 BMW 528i?
It's a documented issue but not catastrophic. 5 complaints have been filed. Repairs average $2,500 and most owners catch it before it causes a breakdown.
At what mileage does the powertrain typically fail?
Based on the 5 complaints filed, powertrain issues most often appear around 54,333 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $2,500 for powertrain repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to powertrain?
No active recalls currently cover powertrain issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2014/BMW/528i.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.