This TSB provides a procedure to diagnose and replace, if necessary, an automatic transmission with Incorrect Ratio DTC (transmission clutch slip in gear above limit) listed on Page 2.
full bulletin at NHTSA ↗2015 Hyundai Santa Fe Sport powertrain problems
moderate 7 complaints filed with NHTSA · avg repair $2,500 · see powertrain across all vehicles →
Complaints
7
Recalls
0
Avg fix
$2,500
When does it fail?
Of the 7 powertrain complaints filed for the 2015 Hyundai Santa Fe Sport, here's the actual mileage breakdown — failures cluster heaviest at 25,000-50,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
What stands out
No new NHTSA powertrain complaint has been filed on this vehicle in over 7 years — the issue may be aging out of the active population.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering powertrain on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993), combined with an anti-theft steering wheel lock campaign (Campaign P32), in response to an increase in thefts of certain 2011-2022MY Hyundai vehicles not equipped with engine immobilizers targeted through social media. For certain vehicles that cannot be updated with the software (Campaign 993), Hyundai is offering customers steering wheel locks at the dealer (Campaign P32). This Dealer Best Practices Guide provides information to assist dealership personnel with customer questions relating to the immobilizer software upgrade, window decals and steering wheel lock ant-theft solutions available from
full bulletin at NHTSA ↗If you are servicing an applicable vehicle with the following symptoms and DTC, follow the Service Procedure on Page 4. ï· Check Engine light on ï· DTC P0880/P088000 - TCM Power signal error open/short ï· Transmission stuck in 4th gear fail-safe ï· Harsh shift into Reverse and Drive
full bulletin at NHTSA ↗The automatic transmission warranty repair policy authorizes in-dealership repairs of the following components for both OEM (new) and remanufactured automatic transmissions:
full bulletin at NHTSA ↗If you are servicing an applicable vehicle with a âCheck Engineâ light on and one or more of the DTC listed below, follow the repair procedure and replace the related solenoid and oil pressure harness.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 3 most recent
Was driving on highway and heard a loud noise and car just stock. I read that old models have same problem. I inspected the car and figure that axle shaft turns inside of transmission and broke it from inside.
The contact's sister owns a 2015 Hyundai Santa Fe Sport. The contact stated that while his sister was driving and following him on the highway at 60 MPH, the vehicle shut off without warning. His sister managed to pull the vehicle off to the side of the road and had the vehicle towed to the residence. Prior to the failure, the contact had taken the vehicle to a dealer where she had the vehicle…
I am writing to express my concern regarding an ongoing and persistent issue with excessive engine oil consumption in my 2015 Hyundai Santa Fe, Subject: Severe Oil Consumption Issue - 2015 Hyundai Santa Fe - VIN: [XXX] The vehicle consumes an alarming amount of oil, approximately 1 quart every 300 miles. This rate of consumption is far beyond what is considered normal and strongly suggests a…
Had powertrain trouble with your 2015 Hyundai Santa Fe Sport?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the powertrain problem on the 2015 Hyundai Santa Fe Sport?
It's a documented issue but not catastrophic. 7 complaints have been filed. Repairs average $2,500 and most owners catch it before it causes a breakdown.
At what mileage does the powertrain typically fail?
Based on the 7 complaints filed, powertrain issues most often appear around 57,680 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $2,500 for powertrain repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to powertrain?
No active recalls currently cover powertrain issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2015/Hyundai/Santa Fe Sport.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.