This bulletin provides important checkpoint guidelines when performing engine oil and filter change services.
full bulletin at NHTSA ↗2016 Hyundai Azera engine problems
moderate Owners of the 2016 Hyundai Azera have filed 3 NHTSA complaints about the engine at roughly $3,100 to repair (U.S. federal records, as of August 2026). Source: NHTSA Office of Defects Investigation. See engine across all vehicles →
Complaints
3
Recalls
0
Avg fix
$3,100
| Model year | engine complaints |
|---|---|
| 2012 Azera | 9 |
| 2013 Azera | 14 |
| 2014 Azera | 3 |
| 2016 Azera (this page) | 3 |
When does it fail?
Of the 3 engine complaints filed for the 2016 Hyundai Azera, here's the actual mileage breakdown — failures cluster heaviest at 100,000-125,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
What stands out
Engine accounts for 20% of all owner complaints filed against this vehicle, across 3 categories tracked.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering engine on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Follow the guidelines outlined in this bulletin to inspect and clean or replace certain components of the engine intake system accordingly during engine short block or sub-assembly replacement.
full bulletin at NHTSA ↗This bulletin provides the service procedure for engine connecting rod bearing clearance testing. Perform the procedure outlined in this bulletin to fulfill the Bearing Clearance Test inspection requirements to determine next required steps.
full bulletin at NHTSA ↗This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below.
full bulletin at NHTSA ↗Certain 2017-2018 MY Santa Fe (NC), 2016MY Veloster (FS), 2014MY Elantra (MD), and 2016-2017MY Azera (HG) vehicles may experience a warning lamp being illuminated intermittently when starting the engine after replacing the motor driven power steering (MDPS) column & housing. This bulletin describes the procedure to perform the steering angle sensor (SAS) reset using the GDS.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 3 most recent
The contact owns a 2016 Hyundai Azera. The contact stated that the heating system was inoperable. The vehicle was taken to two Goodyear Auto Repair Shops, where it was diagnosed with a head gasket leak. One of the Goodyear facilities replaced the thermostat and the radiator. The contact stated that while driving at 55 MPH, a message that the engine was overheating was displayed. The contact was…
Hello, my car was parked at home and as I turned the engine on, I noticed the red light 'oil pressure' on the dashboard. I checked the oil level and it was very low. On the same day I purchases 2 quarts of oil to keep it at a safe level. The next day I checked the dip stick again and much oil was loss. I was very concerned and finally was able to make an appointment to my mechanic shop for…
Engine overheating without Engine light or any other safety alerts until Engine finally failed
Had engine trouble with your 2016 Hyundai Azera?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the engine problem on the 2016 Hyundai Azera?
It's a documented issue but not catastrophic. 3 complaints have been filed. Repairs average $3,100 and most owners catch it before it causes a breakdown.
At what mileage does the engine typically fail?
Based on the 3 complaints filed, engine issues most often appear around 109,000 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $3,100 for engine repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to engine?
No active recalls currently cover engine issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2016/Hyundai/Azera.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.