This article supersedes TSB 20-2028 to update the description of Labor Operation D. Some 2013-2018 F-150/Expedition/Navigator vehicles equipped with 4-wheel drive (4WD) may exhibit an intermittent grinding noise while driving in 2-wheel drive (2WD) mode most commonly on acceleration. This may be due to a loss of vacuum to the integrated wheel end (IWE) actuators and/or wear of the IWE components. To correct the condition, follow the Service Procedure steps to reprogram the transfer case control module (TCCM) and replace any worn vacuum and/or IWE components.
full bulletin at NHTSA ↗2017 Ford Expedition cruise control problems
severe Owners of the 2017 Ford Expedition have filed 8 NHTSA complaints about the cruise control at roughly $600 to repair (U.S. federal records, as of August 2026). Source: NHTSA Office of Defects Investigation. See cruise control across all vehicles →
Complaints
8
Recalls
0
Avg fix
$600
| Model year | cruise control complaints |
|---|---|
| 2013 Expedition | 5 |
| 2015 Expedition | 12 |
| 2016 Expedition | 14 |
| 2017 Expedition (this page) | 8 |
| 2018 Expedition | 7 |
| 2021 Expedition | 3 |
2crashes
4injuries
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering cruise control on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Some 2017 Expedition vehicles may exhibit a greater than 120 Km/h (75 MPH) overspeed warning in the IPC even though the vehicle has not hit that speed. This my be due to a software error in the cluster. To correct this condition, perform a software update to the IPC using the appropriate Ford diagnostic scan tool. For claiming, use causal part 10849 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 0 most recent
Had cruise control trouble with your 2017 Ford Expedition?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the cruise control problem on the 2017 Ford Expedition?
It's a meaningful issue. 8 complaints have been filed and the failure mode causes operational problems for owners. Repairs average $600.
At what mileage does the cruise control typically fail?
Based on the 8 complaints filed, cruise control issues most often appear around 46,026 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $600 for cruise control repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to cruise control?
No active recalls currently cover cruise control issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2017/Ford/Expedition.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.