2018 Ford F-150 owner complaints

Loss of power while acceleration from a stop sign. Vehicle would not shift into gear and acted like it could only drive very slowly. Repair shop inspected it and stated that the transmission needed work and would cost 8200.00 to fix issue that has a TSB out meaning ford knows about the issue

I have a 10 speed automatic transmission that intermittently works in 2nd and third gears. It began doing this at 60,000 miles. I'm not sure if it is the adaptive learning transmission control module (TCM) or the transmission itself. Ford dealer wants over 10,000 to replace transmission. The car is unsafe when pulling into traffic and it won't accelerate half the time.

My Ford F-150 Supercrew XLT 10R80 10-speed completely failed resulting Ford replacing it with a new transmission unit for a cost to be of 7,300. As the transmission failed at 96,000 miles the gears would be skipped with harsh shifting, not fully engaging 4th gear and at times while driving would refused to shift into any gear and high revs and me unable to accelerate. I was nearly involved in a crash when I would pull out into traffic legally but suddenly unable to accelerate and approaching cara from the rear needed to suddenly brake and change lanes to avoid a collision. All diagnosis was conducted by Ford. At first it cost me approximately 300 for them to drain and fill transmission fluid. When that didn't fix the problem they then said it was the DCF drum failure at a cost of 5000. Whe

1st problem transmission: Hard shifting up and down in certain gears. 3 gear seems the worst. When slowing down to almost stop it down shifts and lurks forward which can cause a safety issue. Loud banging noise when it does this hard shift. 2nd problem when starting the truck up get a loud chain rattle. Think it’s the phaser/cam rattle I keep reading about with no fix. Mileage on my truck is 63,000 miles never tow or haul anything. Crazy ford can sell something like this and be ok with it.

10R80 Transmission Delays when shifting and when it does engage its harsh shifts.

No oil in between changes check engine light came one

The contact owns a 2018 Ford F-150. The contact stated that while driving at an undisclosed speed, the transmission was shifting erratically. The contact stated that the transmission shifted from 1st gear to 7th gear and back to 1st gear. The check engine warning light and an unknown warning light was illuminated after the failure. During an oil change service, the contact described the failure to an independent mechanic, who performed a diagnostic test but found no transmission failure. The contact was advised that NHTSA Campaign Number: 26V375000 (Power Train); recall repair could repair the vehicle; however, the VIN was not included in the recall. The contact notified the manufacturer by telephone. The manufacturer confirmed that the VIN was not included in the recall. The failure milea

Direct failure of Cam phasers and confirmation. This led to erratic engine runtime leading to transmission shifting learned behaviors based on the bogus engine information. This causes erratic hardshifting into drive and most importantly dropping gears on the highway resulting in unsafe driving conditions at random. This includes both random downshifts at highway speed and a similar situation when accelerating the wrong gear is engaged both causing unsafe conditions for the driver and those surrounding. Upon phaser replacement the engine then ran correctly and transmission was reset both KAM tables and learned behavior to rectify the transmission safety challenges. This should at least be a TSB not just a mystery to owners and dealers alike.

The contact owns a 2018 Ford F-150. The contact stated that while accelerating from a stop light, the vehicle failed to properly accelerate and jerked and hesitated. The contact stated that the transmission upshifted from 1st to 3rd gear and then from 3rd to 7th gear. During the failure the WRENCH symbol was displayed. The vehicle was taken to the local dealer to be diagnosed, and it was determined that the transmission needed to be repaired, and the CDF drum need to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 96,000.

I own a 2018 Ford F-150 4WD with approximately 24,600 miles. While traveling approximately 70 MPH on the highway in 2H with cruise control operating, I suddenly heard an extremely loud metal-on-metal grinding/ratcheting noise from the driver's-side front wheel area. The noise caused immediate concern about a possible front wheel or drivetrain failure. I disengaged cruise control and the grinding stopped. Within approximately 50 miles on the same trip, the grinding occurred a second time while again traveling approximately 70 MPH in 2H without cruise engaged. Because of the severity of the noise, I pulled over on the side of the highway and inspected the vehicle. I found nothing visibly wrong and resumed driving. The condition has since occurred two additional times while accelerating fr

Truck will not shift into 7th gear, will down shift to 1st gear once it reaches 6th gear around 40mph. Causing the vehicle back tires to brake and skid and lose control of vehicle.

While driving home from a work appointment in Rockwall, Texas, I entered an intersection with three lanes of uncontrolled cross traffic traveling approximately 35-45 mph. As I accelerated my Ford F-150 equipped with the 10R80 transmission, it started into the intersection and then began sporadically hunting for a gear. The truck suddenly lost nearly all acceleration and slowed to an almost complete stop while I was in the middle of the intersection. Vehicles were approaching me from the driver side, leaving me with almost no ability to get out of their path. I was extremely fortunate that I was not T-boned. This is the second time this truck has experienced a sudden and dangerous loss of acceleration, the first was with a 4th gear slip on an on-ramp. Neither incident was preceded by a warn

Spray on liners of cylinder walls absorbing oil and allowing it to pass through

I own a 2018 Ford F-150 3.5L EcoBoost with approximately 93,000 miles. I am experiencing a repeated cold start cam phaser rattle. This is a known issue addressed by Ford in several TSBs, including 19-2365, yet no recall has been issued. It has been "repaired" once at approximately 40,000 miles only to have the same issue reoccur at which time I was told that rattling at startup is "normal" and "since it doesn't persist it is not an issue". No IC gasoline engine should rattle on startup, and I believe this defect poses long-term reliability concerns and will lead to engine damage and failure during operation. Ford should be held responsible for a widespread design flaw affecting thousands of vehicles. I urge the NHTSA to investigate this recurring issue and hold Ford accountable for consu

Engine has cut off while driving on several occasions. An accident nearly occurred as a result on at least 2 occasions.

The contact owns a 2018 Ford F-150. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 26V373000 (Exterior Lighting) and Customer Satisfaction Program: 25N17 (Rear View Camera Replacement If Required After Dealer Evaluation); however, the failure occurred after the repairs were performed. The contact stated that while driving at an undisclosed speed, the "Parking Brake Engaged" message displayed, and the blind spot sensor became inoperable. An unknown warning light was illuminated. Additionally, the TPMS was inoperable. The vehicle was taken back to the dealer, but the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 86,000.

My 2018 Ford F-150 is experiencing a dangerous loss of braking power, a soft/spongy brake pedal, and brake fluid leaking from the master cylinder into the brake booster. These are the exact symptoms and component failures described in Ford Recall Campaign 25S37 (NHTSA Campaign 25V236). However, when checking my VIN, I am told my truck is excluded from the recall population. Because my vehicle is exhibiting the identical safety defect, the current recall window is too narrow and needs to be expanded to cover my vehicle before a serious collision occurs.

The contact owns a 2018 Ford F-150. The contact stated that the lock mechanism to drop the spare tire was rusted and failed to function as intended. The contact stated that the failure failed to allow for the spare tire from being lowered. No warning lights were illuminated. The local dealer was contacted; however, the vehicle was not diagnosed. However, the dealer confirmed that the lock was rusted. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 105,000.

I was required to complete the recall 24E12 on my 2018 ford F 150 2.7L eco boost XLT. Upon completion the check engine light comes on. I looked into this and this is an ongoing problem with the emissions recall . I scanned for a code and P0430 is coming up. (Catalyst System). I contacted the dealership and ford corporate and they will not help assist in resolving this issue. I explained my vehicle was working fine until the mandatory emissions recall was completed and that under the good will assistance I should be covered for Some compensation fixing this vehicle. I was denied any additional help. I as a loyal customer for many years don’t believe that it is my responsibility to pay a full bill for a new converter when it was their recall that caused the issue on an already perfectly fine

The contact owns a 2018 Ford F-150. The contact stated that the steering wheel cover covering the driver’s side air bag was cracked. The dealer was contacted and stated that a special engineer was needed for the repair because the crack was located on air bag housing. The manufacturer was not made aware of the failure. The failure mileage was approximately 119,000.