For 2015-2024 Ford and Lincoln vehicles equipped with turbocharged engines and customer concern of an engine oil leak, refer to Workshop Manual (WSM), Section 303-00 for oil leak inspection and testing methods. Ford has evaluated turbochargers replaced for oil leak symptoms and although oil may collect on the external surface of a turbocharger, it is extremely rare for a turbocharger assembly to be the root cause of the oil leak. Careful inspection of the turbocharger oil feed and drain tubes should be performed along with the recommended WSM procedures as needed. Warranty claims for turbocharger replacement going forward will be assessed.
full bulletin at NHTSA ↗2018 Lincoln MKZ engine problems
moderate Owners of the 2018 Lincoln MKZ have filed 12 NHTSA complaints about the engine at roughly $3,100 to repair (U.S. federal records, as of October 2026). Source: NHTSA Office of Defects Investigation. See engine across all vehicles →
Complaints
12
Recalls
0
Avg fix
$3,100
| Model year | engine complaints |
|---|---|
| 2014 MKZ | 5 |
| 2015 MKZ | 5 |
| 2016 MKZ | 7 |
| 2017 MKZ | 67 |
| 2018 MKZ (this page) | 12 |
| 2019 MKZ | 7 |
When does it fail?
Of the 12 engine complaints filed for the 2018 Lincoln MKZ, here's the actual mileage breakdown — failures cluster heaviest at 25,000-50,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
What stands out
Among the 9 model years of Lincoln MKZ in our records for engine problems, this one ranks #2 by owner-complaint volume.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering engine on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Some 2018-2019 Edge/Continental, 2018 MKX and 2019 Nautilus vehicles built on or before 1-Aug-2019 and 2018-2019 Fusion/MKZ vehicles built on or before 15-Aug-2019 equipped with a 2.7L EcoBoost or 3.0L EcoBoost engine may exhibit an oil leak from the engine oil pan RTV seal. To correct the condition, follow the Service Procedure steps to replace the oil pan with a new oil pan equipped with a press in place gasket.
full bulletin at NHTSA ↗Some 2015-2018 Edge and 2017-2019 Fusion/MKZ/Escape/MKC vehicles equipped with a 2.0L EcoBoost engine may exhibit a low coolant level, white exhaust smoke and/or a runs rough condition with or without an illuminated malfunction indicator lamp (MIL). Diagnostic trouble codes (DTCs) may include P0300, P0301-P0304, P0316, P0217, P1285 and/or P1299 stored in powertrain control module (PCM). This may be due to coolant intrusion into the cylinder. To correct the condition, follow the Service Procedure to replace the long block engine assembly.
full bulletin at NHTSA ↗Some 2015-2018 Edge and 2017-2019 Fusion/MKZ/Escape/MKC vehicles equipped with a 2.0L EcoBoost engine may exhibit a low coolant level, white exhaust smoke and/or a runs rough condition with or without an illuminated malfunction indicator lamp (MIL). Diagnostic trouble codes (DTCs) may include P0300, P0301-P0304, P0316, P0217, P1285 and/or P1299 stored in powertrain control module (PCM). This may be due to coolant intrusion into the cylinder. To correct the condition, follow the Service Procedure steps to replace the long block engine assembly.
full bulletin at NHTSA ↗Some 2017-2020 Fusion/MKZ and 2017-2019 Escape/MKC vehicles equipped with a 2.0L EcoBoost engine may require replacement of the long block engine assembly. New service kits have been released which include all the one-time-use components required in the service procedure for removal and replacement of the long block engine assembly. Refer to the Ford Electronic Parts Catalog (ECAT) for long block service kit part number by application.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 10 most recent
Check engine light came on. Error code 0302 and 0316 on ODB at dealer. Was advised that engine needed to be replaced due to coolant intrusion into cylinder 2 which cause the vehicle to overheat. Engine has 3200 miles on it. Safety hazard due to engine seizing at high speed and causing an accident due to loss of power. Also possible engine fire due to loss of coolant/overheating.
Around end of May or beginning of June 2026 a check engine light came on in our 2018 MKZ. The code showed cylinder 3 misfire. We called our local Ford dealership for diagnosis. We almost didn't get there as it started to overheat on the way. Once at Ford they diagnosed it with coolant intrusion in cylinder 3. They said this was a known issue and needed a new block. $11,500 for replacement. They…
The contact owns a 2018 Lincoln MKZ. The contact stated while driving 50 MPH, the check engine warning light illuminated. The vehicle was driven to the dealer to be diagnosed. The contact was informed that there was a coolant intrusion into the engine. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 46,000.
Head gasket and long block. I was at risk along with the public. I was driving on [XXX] when the car suddenly started to overheat and would not accelerate anymore. The problem was diagnosed today the coolant is leaking into cylinder 3. The check engine light came on and gave me p303 for a code. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
While driving, the car stalled. I could not restart it. It was towed to Lincoln Dealer and determined that coolant had leaked into the cylinders and seized the engine. This is a known defect on the Ford EcoBoost Engine. Fully aware of the defect, Ford redesigned the engine in 2019 for later models. I am now faced with the huge expense of having Lincoln replace the engine. Ford needs to take…
The contact owns a 2018 Lincoln MKZ. The contact stated while driving 30 MPH, the engine light illuminated. While the vehicle was idling, there was an abnormal sound coming from the vehicle. The vehicle was taken to an independent mechanic, who referred the contact to the local dealer for assistance. The vehicle was towed to the local dealer, where it was diagnosed that there was coolant…
Coolant Intrusion of Cylinder 3, car has less than 50,000 miles total and has been very well taken care of. Has had over a gallon of coolant added within the month of Aug
The contact owns a 2018 Lincoln MKZ. The contact stated that while driving approximately 30-35 MPH, the engine overheated. The contact pulled over and became aware that the coolant reservoir was empty. The contact added coolant to the coolant reservoir. The vehicle was taken to an independent mechanic, where it was determined that there was coolant leaking into the cylinder, which caused engine…
I have been told by a ford mechanic on 7.11.2024, 6 weeks before buying the car that there is coolant intrusion in cylinder 2 and the only fix to this would be to replace the long block that cost a little over 8k, some how some way this vehicle dont have any recalls about this well known issue. This in no way should be on the customer due to a defect by Ford engine in there vehicles.
The engine light came on. The car suddenly wouldn’t go past 35 mph . Thankfully I was on a local road. I had it towed to the dealer and was told that the engine needed to be replaced because coolant leaked into the engine. There were no warning lights except the day of . The car did not give any indication of a leak. Nor was it running hot. Everything was functioning fine.
Had engine trouble with your 2018 Lincoln MKZ?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the engine problem on the 2018 Lincoln MKZ?
It's a documented issue but not catastrophic. 12 complaints have been filed. Repairs average $3,100 and most owners catch it before it causes a breakdown.
At what mileage does the engine typically fail?
Based on the 12 complaints filed, engine issues most often appear around 63,667 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $3,100 for engine repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to engine?
No active recalls currently cover engine issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2018/Lincoln/MKZ.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.