2019 Chevrolet Volt owner complaints

Brand new car suddenly stalled while driving - still had about 10 EV miles left and a full tank of gas when it happened, traveling straight at around 45mph. Messages displayed on dash telling me "propulsion power reduced to 0" and "shift to park", giving me about 30 seconds to pull over before it completely stopped. Restarted car several times, but "initializing wait to shift" and "propulsion power reduced" messages displayed, as well as check engine light. Car would not shift out of park, even to neutral. Luckily I was on a quiet city street at night and not on the freeway, as this could have been extremely dangerous. On star service had me towed to dealership, whose service department said it was a faulty part in the electric engine charging module. They will replace the part. However

Had shift to park appear and car would not shut off. If you play with it it might shut off but will not allow it to restart. Gm is aware of this and has put multiple tsb's out to fix it and now they have a new one. It affects all gen 2 volts and other models. It can strand you if it happens. This should be a recall no one wants to be stranded in the dark anywhere.

When shifted into park, persistent error message that car was not in park. Unable to shut off the car despite numerous manipulations of shift. Few similar preceeding incidents were resolved by shift to drive then back to park. Goes to dealer tomorrow. Car running endlessly is dangerous. What if I could not stay with the car, or the car was on the local ferry. No one has inspected it yet. First time problem occured was in November 2024. Most recent more serious problem occured Friday. I am afraid to use the car since, and have not driven it since.

Vehicle lost propulsion and all power mid turn at approximately 45mph. Powe steering and assisted brakes were gone. Conditions were rainy, resulting in single car crash. Car did not restart. No codes present. Occurred again after repairs at 70mph on highway. Codes P0AC4 and P0C0E indicating Drive Motor Power Inverter B. Despite being under warranty, GM cannot repair, and has no replacement parts. GM has ignored messages requesting buyback per federal law.

2018 Chevrolet volt. Consumer writes in regards to transmission failure. *ld the consumer stated while driving the freeway, the vehicle experienced sudden loss of acceleration. The dealer was made aware of the failure. *js

When shifting to park, the vehicle reports that it is NOT in park. This prevents turning off the vehicle. It is difficult to confirm that the vehicle is indeed in the park mode. This is happening more and more frequently and we will contact the dealer for service. I have not called the dealer about this yet.

Intermittent shift to park message when in park. Unable to turn off vehicle.

Shift car issues. The car would not shut off because it doesn’t recognize that the gear is in parking.

The contact owns a 2019 Chevrolet Volt. The contact stated that while the vehicle was shifted to park(P), the message to “Shift to Park” remained displayed. The contact was unable to turn off the vehicle. The contact stated that for approximately 10 minutes, the gear shifter was shifted out of and back into park to be able to turn off the vehicle. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 35,000.

Intermittently, the car would not turn off, starting in about July, 2022. After shifting the car into park and pressing the On/Off switch, the car displayed a message like "Action required. Shift to park". It was impossible to know if the car really was not in park, and would roll into someone, and it was certainly unsafe to walk away and leave the car "on". A Chevy forum showed that this problem is COMMON and pointed me to GM TSB 19-NA-206 (https://static.nhtsa.gov/odi/tsbs/2020/MC-10171895-9999.pdf). The TSB exactly describes the symptom I observed and lists one of the exact parts that the Huston Chevrolet service department replaced on 8/3/2022 - 84733196 N-Harness. The dealer, Chevrolet customer service, and GM customer service all told me that this repair was not covered under warran

About half the time, when I put the vehicle into park, a warning comes up telling me that the vehicle is not in park. I can make the problem go away by wiggling the shift lever. But it is a recurring problem, and it is getting worse.

Vehicle displays error message "shift to park" while vehicle seems to be in park, resulting in a situation in which the vehicle will remain running and energized after driver thinks they have put the vehicle in park, turned it off, and exited.

Driver seat frame has a loud squeak during normal operation of vehicle. Driver seat is a critical safety item, and my concern is that the seat frame has a manufacturing defect.

I am getting "shift to park" error when turning off vehicle. Vehicle does not shut off--problem is defect in the transmission and apparently this is fairly common defect yet there is no recall???

I purchased this vehicle from East Bay BMW in Pleasanton, CA on April 8, 2023. On August 28, 2023, to September 4, 2023, I began to receive messages on the dashboard stating shift to park. The shift lever was in park but was not registering this. I had to wiggle the shift lever to get the message to go away and be able to turn my vehicle off. On September 5, 2023, I had the same issue but this time no matter what I did the message would not go away and I was not able to turn my car off for 10 minutes. On September 5, 2023, I called the dealership and spoke with [XXX] -the Service Advisor who told me he would need to speak with his colleagues and get back to me. As of today September 5, 2023. I have no solution to this problem and cannot drive this vehicle for fear I won't be able to have

This is a Legitimately Serious Concern regarding GM Vehicles (including Chevrolet) and Dealer Service Compliance with "Safety Warnings" and Reliability Warnings as in Factory Service Manuals. Specifically "Single Use Fasteners" and "Do Not Use Air-Impact on Brake System Fasteners" and "TTY Fastener Dual Pass Torque-to-Yield Specifications" . . .  1.) Widespread Non Compliance with Single Use Brake Components (Fasteners, Seals, Bellows) - every set of Brake-Pads / Rotor Replacement should show corresponding Parts Billing.  2.) Shortcuts to Brake System Service by using Air-Wrench removal / installation using Torture-Sticks. 3.) Multiple Different Torque Specifications for each Component / Fastener (upper/lower/front/rear) likely also 'Shortcuts Taken by using Air-Wrench Torque-Stick

Car just stops when the battery control module stops working. Potential to leave us stranded in traffic. Confirmed as a defective part by the dealer.

Vehicle has developed an intermittent issue when placed in park. Displays a message "Attention Needed: Shift to Park" accompanied by audio alerts inside and outside of the vehicle. This is obviously unsafe as the vehicle cannot be parked and turned off reliably. GM Technical Bulletin 19-NA-206 issued in May 2021 (attached) specifically states that that this repair is covered for the Volt by the separate Voltec Component Warranty. GM refuses to honor the warranty.

While driving home one evening, the power steering suddenly failed. A warning message displayed to service the power steering. It became very difficult to steer the car. I had to pull extremely hard on the wheel to be able to make turns. For the turn into my community, I had to make four attempts to get the car to clear the turn through the entrance gate, needing to back up repeatedly and retry. Fortunately I did make it home safely and shut the car down. I made an emergency repair appointment for the next day at a Chevrolet dealership. In the morning the power steering was back. The car was inspected at the dealership. They told me a software update was needed and they charged me $450 to do that.

I was getting on the I15 freeway. After I entered, I set the cruise control and it immediately began to accelerate the vehicle to maximum speed. I was unable to turn it off and had to repeatedly push the brakes to keep the speed below 70 + mph. Smoke from the brakes began to fill the passenger compartment. I got off the freeway and when I slowed to about 20 mph, I heard a clunk under the dash and the cruise control turned off. I drove home the rest of the way without cruise control without incident. I am taking the car to a Chevy dealer today to investigate the cause.