Some 2015-2019 Transit vehicles may exhibit a front wheel bearing type noise or DTCs C0031 and/or C0034 in the anti-lock brake system (ABS) module. If the vehicle exhibits a wheel bearing noise and/or DTCs C0031 and/or C0034, remove the front wheel speed sensor (WSS). Refer to Workshop Manual (WSM), Section 206-09. Using a shop rag, clean any debris from the sensor body as well as the back side of the bearing. If the noise is gone, use the Report a Vehicle Concern link at the bottom of the OASIS report and fill out the form. Monitor OASIS for updates. If the noise or DTCs C0031 and/or C0034 is still present, continue with normal diagnostics. To assist with investigation use the Report a Vehi
full bulletin at NHTSA ↗2019 Ford Transit brakes problems
moderate Owners of the 2019 Ford Transit have filed 5 NHTSA complaints about the brakes at roughly $450 to repair (U.S. federal records, as of July 2026). Source: NHTSA Office of Defects Investigation. See brakes across all vehicles →
Complaints
5
Recalls
0
Avg fix
$450
| Model year | brakes complaints |
|---|---|
| 2015 Transit | 6 |
| 2016 Transit | 4 |
| 2017 Transit | 3 |
| 2019 Transit (this page) | 5 |
| 2020 Transit | 3 |
When does it fail?
Of the 5 brakes complaints filed for the 2019 Ford Transit, here's the actual mileage breakdown — failures cluster heaviest at 25,000-50,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
What stands out
Among the 5 model years of Ford Transit in our records for brakes problems, this one ranks #2 by owner-complaint volume.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering brakes on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 3 most recent
The contact owns a 2019 Ford Transit. While the contact's wife was driving at an undisclosed speed, the brake pedal was depressed; however, the vehicle failed to stop as intended. No warning lights were illuminated. The contact stated that the failure had occurred while the contact's wife was parking the vehicle. The contact stated that the vehicle rolled into the curve and stopped. The contact…
Metal ABS tone ring split and failed resulting in immediate full ABS system failure. ABS system will not work if Tone Ring failure happens just prior to or during incident requiring ABS utilization. From internet research and in message boards, this appears to be a very common failure among Ford Transit 250 and 350 even with low miles. To many. Repair is involved and expensive. These rings…
Brakes totally fail - only occasionally No accidents yet. 2019 Transit 350 XLT, EcoBoost engine. I bought it used: ~ 2 years old, 16K miles. While driving at various speeds: I push down on the brake pedal – and absolutely nothing happens. Pedal goes completely to the floor. Van does not slow down at all. I have flown thru stop signs. Nearly rear-ended a semi. Weird part: This only happens…
Had brakes trouble with your 2019 Ford Transit?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the brakes problem on the 2019 Ford Transit?
It's a documented issue but not catastrophic. 5 complaints have been filed. Repairs average $450 and most owners catch it before it causes a breakdown.
At what mileage does the brakes typically fail?
Based on the 5 complaints filed, brakes issues most often appear around 23,500 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $450 for brakes repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to brakes?
No active recalls currently cover brakes issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2019/Ford/Transit.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.