Some vehicles listed below may exhibit an intermittent airbag warning light and DTC(s) B1763 (OCS ECU Defect), and/or B1764 (OCS Mat Defect) may be stored. Hyundai is extending the warranty coverage of the sensor for the Occupant Classification System (OCS) / Occupant Detection System (ODS) to 18 years/unlimited mileage from the date of original retail delivery or date of first use (whichever occurs first) and is valid for original and subsequent owners. Refer to the warranty and parts information outlilned in this bulletin. This bulletin contains the procedure to inspect for the airbag warning light and DTC(s), replace the OCS (ODS) unit or wire harness, reset the OCS (ODS), and initialize
full bulletin at NHTSA ↗2019 Hyundai Santa Fe XL electrical problems
moderate Owners of the 2019 Hyundai Santa Fe XL have filed 4 NHTSA complaints about the electrical at roughly $850 to repair (U.S. federal records, as of July 2026). Source: NHTSA Office of Defects Investigation. See electrical across all vehicles →
Complaints
4
Recalls
0
Avg fix
$850
When does it fail?
Of the 4 electrical complaints filed for the 2019 Hyundai Santa Fe XL, here's the actual mileage breakdown — failures cluster heaviest at 75,000-100,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
What stands out
No new NHTSA electrical complaint has been filed on this vehicle in over 3 years — the issue may be aging out of the active population.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering electrical on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Some vehicles listed below may exhibit an intermittent airbag warning light and DTC(s) B1763 (OCS ECU Defect), and/or B1764 (OCS Mat Defect) may be stored. Hyundai is extending the warranty coverage of the sensor for the Occupant Classification System (OCS) / Occupant Detection System (ODS) to 18 years/unlimited mileage from the date of original retail delivery or date of first use (whichever occurs first) and is valid for original and subsequent owners. Refer to the warranty and parts information outlined in this bulletin.
full bulletin at NHTSA ↗Some vehicles may exhibit a loss of connectivity or interruptions in the middle of using Bluelink Service functions. This may be due to an irregular disconnection on Verizon’s communication network. Follow the procedure in this TSB to reestablish the connection via the AVN pinhole reset method.
full bulletin at NHTSA ↗A class settlement against Hyundai Motor America (“HMA”) that had alleged that certain 2011 – 2022 model year Hyundai vehicles that were not equipped with an engine immobilizer (called the “Class Vehicles”) contain design flaws, including the failure to manufacture the Class Vehicles with an anti-theft device called an engine immobilizer, that make them susceptible to theft and damage. Class Vehicles manufactured without an engine immobilizer have traditional “turn-key-to-start” ignition systems.
full bulletin at NHTSA ↗A class settlement against Hyundai Motor America (“HMA”) that had alleged that certain 2011 – 2022 model year Hyundai vehicles that were not equipped with an engine immobilizer (called the “Class Vehicles”) contain design flaws, including the failure to manufacture the Class Vehicles with an anti-theft device called an engine immobilizer, that make them susceptible to theft and damage. Class Vehicles manufactured without an engine immobilizer have traditional “turn-key-to-start” ignition systems.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 4 most recent
Purchased vehicle 7/25/2022 at the end of October battery was dead we jumped it. Then when it got cold it would not start jumped it and started. Went bought a new battery the battery in car when we bought it was a 630cca parts store didn’t have a listing for my battery so matched it and got one with 640cca. Next morning would not start. Tried jumping it wouldn’t start that way. Called Hyundai…
The contact owns a 2019 Hyundai Santa Fe XL. The contact stated that there were intermittent, but constant electrical failures with the vehicle. The contact stated that the doors unintendedly locked and unlocked. Additionally, the contact was unable to upload the software updates for the vehicle or connect the vehicle to the Emergency 9-1-1 system through the cell phone. The contact stated that…
2019 HYUNDAI SANTA FE XL- I feel something should be done against Hyundai. I could have easily been killed by their failure in one area. Vehicle wiring harnesses. Are you aware that the wiring systems in many of their vehicles are made from Soy. Soy is a product that is made of Soy Beans and guess that rodents such as mice, chipmunks and squirrels love. Soy Beans. I have had three instances where…
Recall 218 for possible engine fire was issued in early February 2022. 3.5 months later in mid-May there is still no remedy. It has been inconvenient to “park my vehicle outside and away from structures” and to constantly be pulling over when I smell something to make sure my car is not on fire. I can not use my car to go on any long trips for fear it will catch fire. Hyundai should buy my…
Had electrical trouble with your 2019 Hyundai Santa Fe XL?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the electrical problem on the 2019 Hyundai Santa Fe XL?
It's a documented issue but not catastrophic. 4 complaints have been filed. Repairs average $850 and most owners catch it before it causes a breakdown.
At what mileage does the electrical typically fail?
Based on the 4 complaints filed, electrical issues most often appear around 75,000 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $850 for electrical repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to electrical?
No active recalls currently cover electrical issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2019/Hyundai/Santa Fe XL.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.