TECHNICAL SERVICE BULLETIN: ITM REPLACEMENT AND ECM LOGIC IMPROVEMENT (CA2511) - This bulletin provides information to replace the Integrated Thermal Management Module (ITM) and then upgrade the Engine Control Module ‘ECM’ system software on certain K5 (DL3a) vehicles, in the event the Multifunction Indicator Lamp (MIL) is illuminated with DTC(s) P218100, P2181F0, and/or P2181F1 stored. This condition may occur due to degradation of the diaphragm inside the ITM. There are no drivability or other symptoms associated with this condition.
full bulletin at NHTSA ↗2022 Kia K5 engine problems
severe Owners of the 2022 Kia K5 have filed 7 NHTSA complaints about the engine at roughly $3,100 to repair (U.S. federal records, as of August 2026). Source: NHTSA Office of Defects Investigation. See engine across all vehicles →
Complaints
7
Recalls
0
Avg fix
$3,100
| Model year | engine complaints |
|---|---|
| 2021 K5 | 11 |
| 2022 K5 (this page) | 7 |
| 2023 K5 | 6 |
| 2024 K5 | 4 |
| 2026 K5 | 3 |
1fire
When does it fail?
Of the 7 engine complaints filed for the 2022 Kia K5, here's the actual mileage breakdown — failures cluster heaviest at 100,000-125,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
What stands out
Among the 5 model years of Kia K5 in our records for engine problems, this one ranks #2 by owner-complaint volume.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering engine on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
TECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA/KAPPA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on diagnosing and/or repairing some 2011-2024MY vehicles (refer to the table on pages 9 and 10 for applicable models and engine), which may exhibit a symptom of excessive oil consumption.
full bulletin at NHTSA ↗TECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA/KAPPA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on diagnosing and/or repairing some 2011-2024MY vehicles (refer to the tables on pages 8-9 for applicable models and engine), which may exhibit a symptom of excessive oil consumption.
full bulletin at NHTSA ↗VOLUNTARY EMISSIONS SERVICE CAMPAIGN: OWNER NOTIFICATION (SC288) - This document is the owner notification advising that Kia is conducting a Voluntary Emissions Service Campaign on certain 2021-2024 MY K5 vehicles equipped with 1.6L Turbo Gas Direct Injection (GDI) engines to improve the logic in the Electronic Control Module (ECM) to ensure compliance with emissions regulations. Also, the subject vehicles will be inspected and, if necessary, the fuel tank and/or the Purge Control Solenoid Valve (PCSV) check valve will be replaced with a new one.
full bulletin at NHTSA ↗TECHNICAL SERVICE BULLETIN: VOLUNTARY EMISSIONS SERVICE CAMPAIGN: FUEL TANK AND/OR PCSV CHECK VALVE INSPECTION/REPLACEMENT + ECU SW UPGRADE (SC288) - This bulletin provides information to inspect the fuel evaporative system and, if necessary, replace the fuel tank and/or the Purge Control Solenoid Valve (PCSV) check valve on certain 2021-2024MY K5 (DL3a) vehicles equipped with a Gamma II 1.6L T-GDI engine, produced from March 27, 2020 through October 17, 2023. This bulletin also provides information to upgrade the ECU software logic.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 3 most recent
UNKNOWN. Engine misfires. Piston rings
My vehicle is subject to an unrepaired safety recall involving the fuel system. According to the manufacturer’s recall notice, a damaged check valve may allow air to enter the fuel tank, causing the tank to expand and contact hot exhaust components. This can melt the fuel tank, cause fuel leakage, and increase the risk of a vehicle fire. This vehicle has experienced multiple fuel-system-related…
The contact owns a 2022 Kia K5. The contact received notification of NHTSA Campaign Number: 25V794000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer…
Had engine trouble with your 2022 Kia K5?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the engine problem on the 2022 Kia K5?
It's a meaningful issue. 7 complaints have been filed and the failure mode causes operational problems for owners. Repairs average $3,100.
At what mileage does the engine typically fail?
Based on the 7 complaints filed, engine issues most often appear around 89,500 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $3,100 for engine repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to engine?
No active recalls currently cover engine issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2022/Kia/K5.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.