2023 Hyundai Ioniq 5 owner complaints

ICCU failed causing car to be unable to be charged. If driven any further it would have eventually stopped working.

I purchesed the Hyundai ionic 5 2023 from hyandai dealer ship. It had 42 k miles. The car ran good. So I got it. They promised me before the I bought they would charge it up free. When I signed the paper they said they couldn't charge it for me. I drove 5 miles the original battery died. I almost got to accudent only 5 miles away. I figured it was original battery. I change battery. I get tow truck to take home i put new battery in it. Then 5 days later the main iccu stopped charging. Another 12 bolt battery drain. They new it had that problem. Two batteries are main iccu won't charge. They make me sign paper buy as is i didnt think it would die 5 miles later they new it had a serious problem I look on internet the same car had recalls for the same car not on mine My car should have been r

While driving on a 45 mph speed limit road, there was a "pop" noise and then alarms on the dash display that power was limited and stop the car. The car's speed was severely limited to about 10 mph for a few seconds while I pulled the car over, and then the car died. Everything was electrically dead. I couldn't even turn on the hazard lights or lock or unlock the car. I took a video of the dash display rapidly alternating between two alarm messages, "12V battery storage low. Stop safely." and "power limited." This website wouldn't let me upload the video, so I saved screen shots of the two alarm messages from the video. Shortly after I stopped the car, it all went dead. It scares me to think what would have happened if I had been on the interstate when this occurred.

I was sitting in my parked vehicle, which I had just turned on. It was cold so I turned on the seat warmer. About a minute later, I hear a pop and saw a “check electric vehicle system” warning on my dash, followed by an audible alarm and a new “stop vehicle and check power supply” warning on the dash. I decided to have the vehicle towed to my local Hyundai dealer.

I was driving the car 70 miles per hour in a highway. Car suddenly stopped and only go 5 mph. I was lucky no car behind me. If not I could be death today. I brought it to service and ICCU unit failed which is happened almost all Hyundai IONIQ 5. They replaced it with same ICCU and it will happen again. I think they want me to make an accident next time. This car is not safe to drive with this charging unit.

We were driving our vehicle in a parking lot while on vacation and we got an error message “check electric vehicle system”. It then displayed the error message “stop safely and check power supply”. Four months ago, we had the same problem and had our 12 volt battery replaced and our ICCU updated. Our vehicle lost power while we were driving. We were able to drive the car safely to a hotel. But the ICCU needs to be replaced.

Got "check electric vehicle system" warning message when backing into my parking space. Later, when I turned car on to leave, it went into limp mode in the parking lot. Had car towed to Lithia Hyundai of Reno. ICCU failure was determined.

My vehicle has experienced three separate failures of the Integrated Charging Control Unit (ICCU) and two separate 12-volt battery failures. All manufacturer recalls related to the ICCU have been completed. Each of these five events required towing and resulted in either an inability to start the vehicle, or a sudden loss of power while driving, including limp mode. During multiple events, the vehicle displayed a warning message stating “Stop vehicle and check power supply” accompanied by a red battery icon. The sudden loss of power created a serious safety risk to me and to others on the road, particularly when the vehicle lost propulsion unexpectedly. In each case, the vehicle became unsafe or impossible to operate. For every incident, the problem was diagnosed by authorized Hyundai d

Intermittent Electrical / Brake failure . Put vehicle in reverse . Brakes failed to stop vehicle . Vehicle has had electrical issues before . Waring lights came on for steering and tire pressure in the past . Recall then came from Hyundai for the ICCU .45 minutes before the collision, the front collision warning came on when I was stopped at an intersection with no one in front of me . I stopped the vehicle and turned the vehicle off . Turned on the vehicle and it reset the warning lights and sounds , and I continued to drive . Later while pulling out of a parking space in reverse ,I stepped on the brakes but the vehicle did not stop . I pumped the brakes to no avail . After the collision , the brakes worked again when the tow truck driver placed the vehicle on the flatbed .The

This model has known issue. As I found after it occurred to my brand new IONIQ 5 . It has only 320mi. It had 87% battery and all of sudden it stop on road. No power on dashboard. After taking to service station they found “ "Inspected and found code P1A9096- DC/ DC converter input voltage sensor fail. Referenced campaign 997 for concern. With code present, per TSB, replace ICCU and fuse." This same issue I noticed in 2022 after reading forum. After putting my car in service station still I don’t have my car. It’s almost 17 days. If this car had recall I could have saved my time and unnecessary effort. Plus thank god it was local city read( school zone) if I was in highway and same thing happen to me it might be life threatening situations.

On 12/13 while driving back home at a red light at night, we heard a loud pop at the driver's rear side and suddenly the dash displayed a warning stating "Check electric vehicle system". The car then would not drive past 25 mph and kept flashing the warning. We got it home safe, and planned on dropping it off at the dealership the next day after jumping it. The next day however, after multiple attempts to jump the car's battery, it would not start enough to move it. The car would start and then flash a warning saying that the 12V battery voltage is low and then shut off again. It had to be towed on 12/15 to the dealership where they will be doing an diagnosis.

The following is an incident that happened yesterday to my wife, who is an experienced driver: Whilst driving south on I5 from Seatac toward Tacoma in heavy rain with surface spray the screen above the steering wheel mentioned collision avoidance was not working and radar was not working. When I applied the brakes to slow down no response from the brakes. I then let off the brake and tried several times to apply the brakes each time with no success. I still had full control of the steering and could still steer the car. This lasted for about 30s then the brakes started working again. The error messages regarding collision avoidance and radar not working would continue to pop up even after the brakes were working. After stopping the car and turning it off and restarting several hours

While driving on the freeway I heard a pop and a saw a warning notification on the dashboard to check the vehicles electrical system. This was followed by a warning that power was limited which resulted it the vehicle speed decreasing to 30mph, and finally a notice to stop the vehicle immediately. All of this occurred in about 5 minutes time. Thankfully, I was able to pull over to the side of the road without an accident. After this the vehicle became inoperable including hazard flashers. I had to wait on the side of the freeway for about an hour to get a tow. The vehicle was towed to a dealer which confirmed that the ICCU and high voltage fuse were faulty. My safety during this process was put at risk because A) during a snow storm I had to pull the vehicle over to the side quickly across

Car gave an error check electrical system and went into limp mode on highway slowing to 25mph.

I purchased my Hyundai Ioniq 5 on [XXX]. Since then, I have experienced repeated and dangerous failures of the air-conditioning system, which Hyundai and the selling dealership have failed to properly diagnose or repair. On [XXX], while driving, I heard a very loud banging noise coming from the front passenger side of the vehicle. Immediately afterward, the air-conditioning system completely shut down and stopped producing cold air. Before the extreme Arizona heat began, I repeatedly asked Hyundai on Bell Road in Glendale to properly diagnose the A/C system due to ongoing concerns. Despite the vehicle being under warranty, the technician told me I would have to pay a diagnostic fee before they would evaluate the A/C. As a result, the underlying problem was not properly diagnosed or repaire

INCIDENT DESCRIPTION: On November 24, 2025, while driving at ~60 mph on NYS Route 17 (highway) with ~15% battery charge, my 2023 Hyundai IONIQ 5 suddenly entered limp mode and lost motive power. The high-voltage battery state of charge dropped instantly from ~10-15% to 0%, triggering error code P1B9600 (HV battery cell imbalance—cells failing to charge/discharge properly). I was unable to fully remove the vehicle from the roadway. My elderly mother was a passenger; a passing tractor-trailer came within 1 ft of striking us when disabled. NY State Police responded (report available). Required $300 tow to the Hyundai dealer, stranding us 150 miles from home.//PRIOR RELATED FAILURES: 1. November 14, 2025: Stranded due to ICCU failure (recall 24V-868 related) (stranded on NYS State Route 444).

Due to a heavy brake application a water bottle in the back seat spilled and the water traveled under the drivers seat. This resulted in multiple car systems going offline, vehicle reporting LKAS error and inability to turn the car off. This essentially bricked the vehicle. Repair in order to correct the shorts and corrosion from the water both the drivers seat and main floor wiring harnesses require replacement cost estimate approximately $12,000. These key electrical connections under drivers seat are not adequately protected from simple water damage. This in my opinion makes the vehicle unfit for use as a family EV SUV as a simple water bottle still should not be able to brick a car. I consider this a design defect and the manufacturer is not covering this under warranty.

I am reporting a safety concern with my 2023 Hyundai Ioniq 5 related to Hyundai placing remote safety features behind a paid subscription. Hyundai has locked two functions that affect safety: (1) the ability to remotely check the vehicle’s battery state of charge, and (2) the ability to remotely unlock the doors from a phone. These functions previously existed under BlueLink but were removed unless the owner pays for the new Connected Services package. 1. Remote battery status Without paying the subscription, I cannot check the vehicle’s battery level while it is charging. If I need to leave the charging area or am charging from home and not directly watching the dashboard, there is no way to verify whether charging completed or stalled. Charging interruptions are common with EVs. This c

The car was fully charged and all of a sudden displayed a limited power warning and stopped driving completely. We were stuck on a road and had to get a tow truck. The tow truck was able to get power to the battery to drive it up on the bed. It was fully dead -couldn’t even unlock the doors. It’s been at Hyundai for 3 days and they are replacing the ICCU fuse. From what I read this is a very common issue

The car proceeds by itself and does not stop even when brakes are engaged. This happened 2 times. Once in reverse and once forward, both caused severe damages to the car. In the forward incident, the driver was wearing seat belt but air bags deployed with impact.