2024 Ford Expedition owner complaints

I was driving on the I95 and just passed the McHenry tunnel when out of nothing I heared a loud bang and my moon roof spontaneously shattered into pieces. Nothing hit it and after inspection there was also no other damage on the car but the rear part of the moonroof that was completely shattered.

Driver assistance warning lights come on. All safety systems such as blind spot, collision avoidance, and lane keeping fail and are inoperable. This also shuts down cruise control. For has been aware of this issue since December 2024

I purchased this 2024 Ford Expedition brand new from a Ford certified dealer (Conklin Cars, Newton , Kansas). Upon driving off the lot for the first time to a gas station across the street from the dealer, at restart all the sensor gave warnings. Sensors that gave warning include: Blind spots sensors, back-up sensors, Froward impact, lane departure, automatic braking, rear cross traffic, and the cruise display. I took it back to the dealership and the reset the system and upon starting the vehicle after parked, all the sensors stopped working again. I then took the Ford Expedition back to the certified dealer (Conklin Cars, Newton , Kansas) and they game me sheets of paper, Last one give after 4 visits to dealer [XXX]) stating that Ford knows of the an issues, which appear to be right o

I would like to report the seats. I bought my vehicle new. The seats has caused me to have medical issues. It has also caused one other person issues too, so it was not just me. I have never had any sort of back or leg issues before getting this vehicle. I now have severe Sciatica Nerve problems. Which, I have seen the Doctor for. It flares up so bad while I am driving my right leg goes into extreme pain then it goes numb. Which is not helpful since this is the foot I use the gas and brake with. This is my only transportation, so I do not have another vehicle to drive. I have had my son drive this vehicle when we went on a trip. I sat in the middle row captain chair and it was the same issue. This trip was when my daughter in-law (Which is an RN) starting having the same issues as

Was rear ended on highway and both driver and passenger seats upon impact where laid back.

The fuel line/fuel pump was leaking. Smelled fumes from the gasoline. Fuel was leaking over the fuel tank from the top of the tank. The vehicle was drivable when fuel was leaking. Very concerned that their could have been a fire due to the fuel leak. Took the vehicle to the Ford service department where it was purchased. Service shop stated that during inspection they noticed that something chewed through the fuel line/fuel pump. Comments made by the service advisors stated that they have seen squirrels/rodents attracted to the soy based ingredients of the parts/wiring. The repair would not be covered under warranty due to "outside influence". The manufacturer is installing a similar part and not covering under warranty. No warning lights; no warning messages. If the same type o

I am filing this complaint regarding Ford Safety Recall 25S49 (NHTSA Campaign Number 25V315). My vehicle is a 2024 Ford Expedition Max, VIN [XXX] . The Ford pass app and the Ford recall site both show the remedy for the recall as "Available", but when I contact my dealer (Maxwell Ford in Austin, TX) they say that the repair cannot be performed because the update is not yet active in the Oasis dealer system. Ford has had months to release the software fix, but continues to delay the rollout to dealerships. Meanwhile, I have been without my vehicle because the rearview camera is unreliable and considered a safety hazard under the recall. I am paying for a new vehicle that is parked at the dealership and undriveable due to Ford's failure to provide a timely remedy. I have contacted Ford

Malfunction: powered running board on the passenger side of vehicle while vehicle was in park with door open and engine running. It closed while my hisband was resting his right foot on it and then it opened and closed and his foot and lower ankle was getting crushed. I had to run around to passenger side and when I opened the right rear passenger door the running board released and opened up. The car will be going to the dealer for its first oil change etc. and I will talk to them about this incident.

Passenger sideview mirror does not open upon unlocking and starting the vehicle. I need to stop (if started driving) turn to park, turn off car, open driver's door to signal car that I have left, lock car using remote, wait few seconds and then unlock to reset car then it usually opens. Issues with mirror began happening a month after purchasing brand new car (5/24), first mirror was "popping or clicking" upon turning outright, mirror had been replaced once, over last year issue has been on going and brought to dealershop " deemed a technological glitch" - no warning lights or messages appear - sometimes my control panel screen will turn black upon starting the car which I now know means to look at my passenger mirror. This last occurred on Friday 7/25/25.

At highway speeds, the car shakes/vibrates. It's scary. Took vehicle to Ford service. They identified the problem, acknowledged that it exists and was unable to fix it. Now, I'm stuck with this car that shakes and seems unsafe as it shakes. Additionally, was told by the Ford dealer that other Ford Expeditions have come in with the same problem and have been unable to remedy. Even with a case open with the Ford engineers, they were unable to fix. Ford Motor company has been contacted about the issue along with the executive offices of Ford and the CEO.

The contact owns a 2024 Ford Expedition. The contact stated that while driving at various speeds, the message "Drive Assist Unavailable" was displayed. The contact stated that when the vehicle was turned off and restarted, the system was functional. The contact had taken the vehicle to a local dealer, who checked the 12-Volt battery and found that the battery was operational and there were no other electrical issues. The contact stated that later, while starting the vehicle, the message "Loss of Power Steering Assist" was displayed, and the steering wheel was difficult to turn to the left or the right. The vehicle was turned off and restarted, and regained power steering functionality; however, the failure reoccurred. The contact attempted to reset the electrical system by disconnecting th

The contact owns a 2024 Ford Expedition. The contact stated that while driving on several occasions at speeds between 60 MPH - 80 MPH, the vehicle was shaking abnormally. The vehicle was taken to the dealer approximately six times however, the dealer was unable to duplicate the failure. The manufacturer was notified of the failure. The failure mileage was approximately 5,000.

I own a 2024 Ford Expedition XLT. The vehicle repeatedly loses multiple federally mandated safety systems including Blind Spot Monitoring, Cross-Traffic Alert, Automatic Emergency Braking, Forward Collision Warning, and camera systems. Alerts include: ‘Cross-Traffic System Fault,’ ‘Blind Spot System Fault,’ ‘Pre-Collision Assist Not Available,’ ‘Front Camera Fault,’ and ‘Check Parking Sensors.’ Ford has acknowledged this as a known issue with a fix delayed until June. My dealer (Morries Ford, Buffalo MN) is charging $225 each time the defect recurs just to clear errors. This is a safety defect that places my family at risk. Ford is refusing to cover the full repair cost and the dealer is charging for temporary resets.

The 2024 Ford expedition brakes was not working at the time of the accident, we later found that there was a recall on the brakes. PMA companies is the TPA for the Victaulic Companies, please see accident description below: Insured driver states she Pulled in driveway and was trying to park vehicle. Driver hit the brakes all the way down and the vehicle did not stop. Vehicle went through drivers fence and struck a tree causing damages to vehicle. Caused damages to neighbors fence.

I am the owner of a 2024 Ford Expedition, purchased new in March 2024. I am writing to formally report multiple instances of complete brake failure, which pose a significant safety risk. The most recent incident occurred on [XXX], at approximately [XXX], while I was driving northbound on [XXX] in Cupertino, California, with my wife and two grandchildren (ages [XXX] and [XXX]) in the vehicle. As I approached the [XXX] exit, I began decelerating. While applying continuous pressure on the brake pedal during the descent of the off-ramp, the brake pedal suddenly went soft and sank to the floor. The vehicle failed to slow down and began accelerating downhill, due to gravity, toward the intersection at [XXX] , where the light was red. This total loss of braking control lasted for approximately

My wife tried to move my expedition from spot to another in our parking lot During that maneuver the gas pedal assembly broke down and the car in high speed created some personal and property damages I have the part handy and ready for inspection up on request The insurance knows about it And I had a police report No warning prior to the incident

The contact rented a 2024 Ford Expedition. The contact stated that while driving 60 MPH with the Adaptive Cruise Control activated, upon passing a speed limit sign the vehicle independently accelerated to 80 MPH. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was not taken to the dealer nor an independent mechanic. The vehicle was not repaired. The rental agency was not notified of the failure. The manufacturer was not notified of the failure. The failure mileage was 24,000.

The contact owns a 2024 Ford Expedition. The contact stated while driving at an undisclosed speed, the vehicle was shaking and vibrating. The contact stated that the failure was present at various speeds. The vehicle was taken to the dealer several times regarding the failure, however the failure was not duplicated. The contact stated that the dealer replaced and balanced all four tires, however the failure reoccurred. The vehicle was not repaired. In addition, the dealer requested that the vehicle be inspected by the engineer, however, the request was denied by the manufacturer. The manufacturer was made aware of the failure but did not assist. The contact was advised to contact the NHTSA Hotline and report the failure. The failure mileage was approximately 150. The VIN was not ava

Vehicle was driving approximately 65 miles per hour on interstate. Upon crossing a bridge the sunroof exploded sending glass flying inside the vehicle. The vehicle was equipped with a dash camera which also captured audio. No external object struck the vehicle. Two children and an adult in the vehicle were struck with flying glass. The video has been saved and can be provided in addition to the pictures.