Free. Instant. No signup. Pulls recalls and complaints for your exact vehicle.
Couldn't find that VIN. Check the digits and try again.
2024 Rivian R1S suspension problems
severe
Owners of the 2024 Rivian R1S have filed 4 NHTSA complaints about the suspension at roughly $900 to repair (U.S. federal records, as of September 2026). Source: NHTSA Office of Defects Investigation.See suspension across all vehicles →
Rivian Automotive, LLC (Rivian) is recalling certain 2022-2025 R1S and R1T vehicles that previously had service performed
The toe link joint may separate, increasing the risk of a crash.
Fix: Rivian will replace the rear toe link bolts, free of charge. Owner notification letters were mailed February 17, 2026. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1794. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning February 24, 2026.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering suspension on this vehicle — documented
repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall
(it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Service BulletinRCA-18-24-001-3Aug 2025
Rivian is initiating a customer satisfaction campaign for some model year 2023-2024 R1T and R1S vehicles. On these vehicles, the wheel hub to knuckle joint may have been assembled with an updated fastener using a torque value intended for the previously-used fastener. A fastener torqued to the previously-used lower value may cause an audible noise while driving at low speeds but will not impact vehicle performance. Rivian will retorque the affected fasteners and, if necessary, replace them. Rivian is launching this campaign for customer satisfaction and to ensure the quality of Rivian vehicles. Note: This document supersedes RCA-18-24-001-2. Revision 3 updates the approximate build dates.
Rivian is initiating a customer satisfaction campaign for some model year 2023-2024 R1T and R1S vehicles. On these vehicles, the wheel hub to knuckle joint may have been assembled with an updated fastener using a torque value intended for the previously-used fastener. A fastener torqued to the previously-used lower value may cause an audible noise while driving at low speeds but will not impact vehicle performance. Rivian will retorque the affected fasteners. Rivian is launching this campaign for customer satisfaction and to ensure the quality of Rivian vehicles.
Rivian is initiating a technical service bulletin for some 2022-2024 R1T and R1S vehicles. In some situations, the driver may notice a squeaking or chirping noise coming from the front of the vehicle when driving on uneven surfaces below 32 km/h (20 mph). This condition does not affect vehicle performance. Upon customer complaint of this squeaking or chirping noise, Rivian will replace the front hydraulic jounce lines with upgraded components to eliminate the noise.
Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting
4 most recent
suspension
· filed 12/04/2024
Rivian has a 'kneel' option that uses the powered air suspension to lower the vehicle to make entry and exiting the vehicle easier for users. Yes, this can be turned off or on. When on, the function stops if a main door (driver/passenger) is open and left open the car will not continue to kneel for safety purposes. However, it does NOT stop if you are using the rear hatch to access anything.…
suspension
· filed 09/03/2026
At 56,083 miles, my 2024 Rivian R1S experienced a suspension warning while driving on the US-101 Freeway and entered reduced-performance/turtle mode, limiting the vehicle to approximately 50 MPH while surrounding traffic was traveling substantially faster. The sudden speed differential created a serious highway collision risk. Rivian inspected the vehicle and diagnosed fault P12DF7A, “Roll…
suspension
· filed 05/29/2025
clunking/thumping noise coming from front end over speed bumps like something is loose or going to fall apart. have taken car into service few times and was told its normal, its getting worse. Online forum threads have mentioned same issue , I am afraid one of these days something going to snap and cause a breakdown or even worse terrible accident.
suspension
· filed 04/14/2026
On [XXX], I was driving my Rivian R1S on [XXX] in the far left lane at highway speed on a smooth, straight road when I suddenly and completely lost control of the vehicle without warning. The vehicle swerved right, struck a vehicle in the middle lane, then veered left, spun, and collided head-on with the guardrail on the right side of the road. I was evaluated at the scene by EMT. There were no…
Had suspension trouble with your 2024 Rivian R1S?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the suspension problem on the 2024 Rivian R1S?
It's a meaningful issue. 4 complaints have been filed and the failure mode causes operational problems for owners. Repairs average $900.
At what mileage does the suspension typically fail?
Mileage data is limited for this issue. Owners report failures across a wide range, suggesting cause is more about driving conditions and maintenance than mileage alone.
What does it cost to fix?
Independent shops typically charge around $900 for suspension repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to suspension?
Yes — 1 active recall(s) cover suspension issues on this vehicle. Recall fixes are always free regardless of mileage or warranty status. Use the VIN decoder at the top of the page to check if your specific vehicle is affected.
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2024/Rivian/R1S.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.