This informational bulletin instructs the tech when fuel/fluid is needed to be tested and where it can be sent for analysis.
full bulletin at NHTSA ↗2025 Chevrolet Tahoe brakes problems
moderate 5 complaints filed with NHTSA · avg repair $450 · see brakes across all vehicles →
Complaints
5
Recalls
0
Avg fix
$450
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering brakes on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
This Preliminary information communicates an issue with ABS SES MIL / Service Brake System / Service StabiliTrak / BSCM DTC P0606 P0562 and dealers to perform additional battery and connection testing.
full bulletin at NHTSA ↗This Preliminary information communicates an issue with ABS SES MIL / Service Brake System / Service StabiliTrak / BSCM DTC P0606 P0562 and engineering is currently investigating.
full bulletin at NHTSA ↗This service bulletin provides customer information for rear unwanted automatic braking, usually when reversing out of a garage or driveway.
full bulletin at NHTSA ↗This bulletin advises the dealers to maintain the vehicle stock on hand by doing a full inspection on the vehicles before being sold (prepping) to the customer.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 4 most recent
Brake system failure. Brakes were all but gone as I couldn't safely stop my car at an intersection and had to quickly cut in front of on coming traffic to go into a gas station to avoid running a red light.
I am reporting a critical safety design defect in my 2025 Chevrolet Tahoe Z71 (VIN: [XXX] ), involving the Brake Pedal Assembly geometry. Bought vehicle in January this year and within a few days of driving I noticed my foot repeatedly catching or hanging up on the brake pedal when moving from the accelerator to brake, which severely delays braking application (regardless of my footwear). This…
Driving along the highway in cruise control at about 70mph without any trailer being pulled. Suddenly I got brake errors. ABS, ESC, Trailer brake error failures all popped on the dash warnings. Brakes were unresponsive only applying hard pressure to the brake pedal was effective. There was zero feedback from the brake pedal to myself on it engaging and braking effectively. If this happened in a…
I am filing a safety complaint regarding my 2025 Chevrolet Tahoe Premier for repeated brake assist/braking failures. Most recent incident: While driving, the check engine light came on. I turned the vehicle off for approximately 10 minutes and restarted it, but the check engine light remained on. Approximately 20 minutes later, multiple warnings appeared on the dash including: “Brake Assist…
Had brakes trouble with your 2025 Chevrolet Tahoe?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the brakes problem on the 2025 Chevrolet Tahoe?
It's a documented issue but not catastrophic. 5 complaints have been filed. Repairs average $450 and most owners catch it before it causes a breakdown.
At what mileage does the brakes typically fail?
Mileage data is limited for this issue. Owners report failures across a wide range, suggesting cause is more about driving conditions and maintenance than mileage alone.
What does it cost to fix?
Independent shops typically charge around $450 for brakes repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to brakes?
No active recalls currently cover brakes issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2025/Chevrolet/Tahoe.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.