This technical bulletin provides a procedure to complete a terminal replacement or connector re connection to correct a condition of Diagnostic Information for Supplemental Inflatable Restraint (SIR) System, Intermittent AIR BAG Indicator/Lamp Illuminated with DTC(s) B0012, B0013, B0015, B0016, B0019, B0020, B0022, B0023, B0026, B0033, B0040, B0042 or B0044 Set (Inspect and Replace Connector Position Assurance (CPA) Retainer)
full bulletin at NHTSA ↗2006 Chevrolet Monte Carlo airbags problems
critical 7 complaints filed with NHTSA · avg repair $1,100 · see airbags across all vehicles →
Complaints
7
Recalls
0
Avg fix
$1,100
7crashes
11injuries
1fatality
When does it fail?
Of the 7 airbags complaints filed for the 2006 Chevrolet Monte Carlo, here's the actual mileage breakdown — failures cluster heaviest at 150,000+ mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
What stands out
No new NHTSA airbags complaint has been filed on this vehicle in over 18 years — the issue may be aging out of the active population.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering airbags on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
GENERAL MOTORS: DIAGNOSTIC INFORMATION FOR INTERMITTENT RESTRAINTS, AIR BAG (SIR) INDICATOR/LAMP ON WITH DTC(S) B0012, B0013, B0016, B0016, B0019, B0020, B0022, B0023, B0026, B0033, B0040, B0042 OR B0044 SET. THIS MAY BE CAUSED BY A LOOSE, MISSING, OR BROKEN CONNECTOR POSITION ASSURANCE (CPA) RETAINER AT THE AIR BAG FOR THE SET DTC. INCLUDES TRAILBLAZER EXT. UPDATED 8/16/10. UPDATED 3/12/12.
full bulletin at NHTSA ↗BUICK/CADILLAC/CHEVROLET/GMC: AIRBAG LIGHT ON, DTC B0071 AND B0081 SET (DIAGNOSE AND REPLACE RIGHT FRONT SEATBELT BUCKLE, IF NECESSARY). UPON INVESTIGATION, THE TECHNICIAN MAY FIND DTC B0071 SET IN THE PASSENGER PRESENCE SYSTEM (PPS) AND A DTC B0081 IN THE SENSING AND DIAGNOSTICS MODULE (SDM).
full bulletin at NHTSA ↗AIR BAG READINESS LIGHT ON, DTC B1019 SET IN SENSING AND DIAGNOSTIC MODULE (SDM) (REPROGRAM INSTRUMENT PANEL CLUSTER (IPC)).
full bulletin at NHTSA ↗AIR BAG INDICATOR LIGHT IS ON. UPDATED ON 12/13/07.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 3 most recent
Serious rear-end, overlapping collision with 2006 Chevrolet monte carlo and tractor trailer. Extensive front-end damage. Critical injuries to driver and no airbag deployment. Airbag did not appear to be functioning properly as no event was recorded on module. *tr
Car malfunction my passenger who was my babymamma pasaed away
Tl* the contact owns a 2006 Chevrolet monte carlo. While traveling approximately 50 MPH, the contact swerved to avoid a vehicle and crashed into a light pole. The air bags failed to deploy. A police report was filed. The contact sustained injuries to the spine, neck, and back. The passenger sustained injuries to the neck and back. The contact and the passenger received medical attention. The…
Had airbags trouble with your 2006 Chevrolet Monte Carlo?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the airbags problem on the 2006 Chevrolet Monte Carlo?
It's a serious issue. 7 complaints have been filed, including 7 reports involving a crash and 1 fatality(ies). We've classified it as critical based on NHTSA's reported outcomes.
At what mileage does the airbags typically fail?
Based on the 7 complaints filed, airbags issues most often appear around 113,667 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $1,100 for airbags repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to airbags?
No active recalls currently cover airbags issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2006/Chevrolet/Monte Carlo.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.