This is a Technical Journal: Text plus 2 PDFs and 1 .PNG Oil Consumption test. Perform the test. Follow service procedure Description and Service sections updated to clarify that vehicle reports are not required.
full bulletin at NHTSA ↗2007 Volvo S80 engine problems
moderate 3 complaints filed with NHTSA · avg repair $3,100 · see engine across all vehicles →
Complaints
3
Recalls
0
Avg fix
$3,100
What stands out
No new NHTSA engine complaint has been filed on this vehicle in over 6 years — the issue may be aging out of the active population.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering engine on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Engine Control Module (EMS) Software (MSW) Information â August 2022; Improvement List (Change Log) - US21+OBD22 (13L VGT, TC) And US17+OBD22 (11L) Emissions
full bulletin at NHTSA ↗This is a Technical Journal: Oil in cooling system. New cleaning method developed.
full bulletin at NHTSA ↗This is a Technical Journal: Oil in cooling system. New cleaning method developed.
full bulletin at NHTSA ↗This is a Technical Journal: Oil in cooling system. New cleaning method developed.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 3 most recent
This car really has a bad transmission problem and it jerks soo bad it been doing that for a long time
Oil leaking from hole or cracked engine alot of oil dripping in the exaust pipes very danger situation
2007 Volvo s80. Consumer writes in regards to vehicle stalls while driving. *smd the consumer stated when he moved into the fast lane, the engine stalled. He kept the vehicle in drive, where it attempted to start, but it would only run for 5-6 seconds. The vehicle was towed to the dealer. According to the service invoice, the MAF sensor was bad and the air filter had become wet at some point.…
Had engine trouble with your 2007 Volvo S80?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the engine problem on the 2007 Volvo S80?
It's a documented issue but not catastrophic. 3 complaints have been filed. Repairs average $3,100 and most owners catch it before it causes a breakdown.
At what mileage does the engine typically fail?
Mileage data is limited for this issue. Owners report failures across a wide range, suggesting cause is more about driving conditions and maintenance than mileage alone.
What does it cost to fix?
Independent shops typically charge around $3,100 for engine repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to engine?
No active recalls currently cover engine issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2007/Volvo/S80.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.