Some 2011-2012 F-250/F-350 and 2011-2015 F-450/F-550 vehicles equipped with a 6.7L diesel engine built on or before 9-Dec-2014 may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P2043, P205C and/or P205D. Follow the Service Procedure steps to correct the condition.
full bulletin at NHTSA ↗2012 Ford F-250 fuel system problems
moderate 3 complaints filed with NHTSA · avg repair $1,200 · see fuel system across all vehicles →
Complaints
3
Recalls
0
Avg fix
$1,200
When does it fail?
Of the 3 fuel system complaints filed for the 2012 Ford F-250, here's the actual mileage breakdown — failures cluster heaviest at 100,000-125,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
What stands out
No new NHTSA fuel system complaint has been filed on this vehicle in over 9 years — the issue may be aging out of the active population.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering fuel system on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 1 most recent
I got on the highway and was doing a turnaround when I accelerated to enter the highway lanes a warning light that said reduced engine power appeared on my dash. Approximately 200' later my truck died on the highway. My high pressure fuel pump went out and apparently disintegrated sending aluminum shavings throughout my entire fuel system. The fix is to replace the entire fuel system at a cost of…
Had fuel system trouble with your 2012 Ford F-250?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the fuel system problem on the 2012 Ford F-250?
It's a documented issue but not catastrophic. 3 complaints have been filed. Repairs average $1,200 and most owners catch it before it causes a breakdown.
At what mileage does the fuel system typically fail?
Based on the 3 complaints filed, fuel system issues most often appear around 109,667 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $1,200 for fuel system repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to fuel system?
No active recalls currently cover fuel system issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2012/Ford/F-250.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.