Some 2010-2020 vehicles may exhibit distorted glass with a subtle orange peel pattern or streaking etched into the surface. This is caused by hydrofluoric acid which is used in some car wash solutions as a cleaning agent. Hydrofluoric acid can attack the glass and cause visual distortion and/or discoloration on the outer surface which cannot be removed by further cleaning. If this type of distortion is found, inspect the area of the glass that is covered by the cowl and/or molding. The portion of glass that is covered by the cowl or molding will not be affected by the acid. Hydrofluoric acid damage is not a defect in material or workmanship and is not a warrantable condition.
full bulletin at NHTSA ↗2017 Ford E-450 visibility problems
moderate 3 complaints filed with NHTSA · avg repair $350 · see visibility across all vehicles →
Complaints
3
Recalls
0
Avg fix
$350
When does it fail?
Of the 3 visibility complaints filed for the 2017 Ford E-450, here's the actual mileage breakdown — failures cluster heaviest at 0-25,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
What stands out
No new NHTSA visibility complaint has been filed on this vehicle in over 6 years — the issue may be aging out of the active population.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering visibility on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 3 most recent
The windshield wiper does not adequately clear the drivers view. It's travel stops near the midpoint of the drivers view leaving much of the road including part of driving lane and the oncoming lanes. Both manufacturer and dealership have been involved and acknowledge they have received numerous complaints. Manufacturer through customer service says they have been making it that way for 5…
Thor 2017 vegas motorcoach--windshield wiper system does not clear drivers side of windshield enough to see road in rain or snow conditions.
Tl* the contact owns a 2017 Ford e-450. While the contact's husband was driving 50 MPH, the front passenger window fractured. The vehicle was not taken to a dealer to be diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 2,000.
Had visibility trouble with your 2017 Ford E-450?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the visibility problem on the 2017 Ford E-450?
It's a documented issue but not catastrophic. 3 complaints have been filed. Repairs average $350 and most owners catch it before it causes a breakdown.
At what mileage does the visibility typically fail?
Based on the 3 complaints filed, visibility issues most often appear around 6,000 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $350 for visibility repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to visibility?
No active recalls currently cover visibility issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2017/Ford/E-450.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.