2018 Ford Fusion owner complaints

The contact owns a 2018 Ford Fusion. The contact stated that while driving at various speeds, the engine was running rough. Additionally, the A/C was making a loud squealing sound while activated. The contact stated that upon inspecting the vehicle, the contact became aware that the coolant level was low. There was no warning light illuminated. The vehicle was taken to the dealer it was purchased from, and the water pump kit timing belt was replaced. The vehicle remained at the dealer. The contact was unable to confirm that the vehicle had been repaired. The contact related the failure to Ford Campaign Number: 21N12; however, the campaign had expired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 101,000.

The car was taken to the repair shop due to reduced speed and shaking. The repair shop mentioned that a bulletin for the car indicated that coolant could leak into the engine. They reported that the coolant had indeed leaked onto the engine, causing the gasket to blow. The dealer was contacted and was informed that it was an extended warranty of up to 84000/ 7 years. so I was referred to NHTSA Case S3H0j5

Block cracked internally inside cylinder number 2 causing a misfire, white smoke on start up, coolant lose, and overheating. Problem is called coolant intrusion. Safety is at risk is the car dies on the interstate. It has a check engine light for misfire on cylinder 2. Ford is aware of this problem but says my vin is not affected by this problem even though I have this problem.

Purchase car in 2019. 4 years later my car is overheating due to a cylinder crack. No recall was found using my vin number but with a cylinder crack and car overheating this is a safety issue.

The contact owns a 2018 Ford Fusion. The contact stated while driving at an undisclosed speed, there was a knocking sound coming from the engine. There was no warning light illuminated. The vehicle was restarted; however, the failure recurred. The vehicle was taken to the dealer and was diagnosed with coolant intrusion into the cylinder, causing engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The approximate failure mileage was 115,000.

Vehicle’s engine was misfiring for a while before check engine light came on. Showing cylinder 2 misfiring codes when scanned. The first dealership replaced the spark plugs, didn’t fix the issue. The next dealership said I have coolant intrusion and need to replace engine.

I have a 2018 ford fusion 2.0L ecoboost with around 77k miles and started to see coolant loss with no visible signs in engine bay or below.car, rough start with error P0316 and occasional misfire. White smoke comes from exhaust on start sometimes. Also have to fill coolant every other day or so. It looks as coolant intrusion issue very common with these engines.

The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the temperature gauge indicated that the engine was overheating, and the vehicle briefly shuddered. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed failures with the head gasket and turbo charger. The vehicle was not repaired. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 75,000.

The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle started shuddering violently, hesitated, and failed to accelerate to approximately 35 MPH. The check engine warning light was flashing. The contact related the failure to the Customer Satisfaction Program: 21N12. The vehicle was towed to the local dealer, where it was diagnosed with coolant intrusion into the cylinders. The dealer informed the contact that the engine small block needed to be replaced, but a full engine replacement was recommended. The vehicle was not repaired. The manufacturer was contacted and filed a complaint. The manufacturer advised the contact that a future report would be issued. The failure mileage was approximately 100,000.

My cars coolant is leak and I don't know where it goes. It overheats and the coolant continually needs to be added. The coolant cap has cracked twice and its is hard to find a replacement cap and we can't drive the car. I have taken it to two auto repair shops, and they said the issue can NOT be fixed. I am in fear of it overheating all the time. This is causing me fear and I believe it is dangerous and I am stuck paying for a car I can't drive.

On four separate occasions the truck will randomly open while driving. After the first couple times I was extremely careful to ensure I did not randomly hit the button or had my key fob in a way that the truck release could be activated by accident. Despite this the truck will still randomly open on its own. Could be a very dangerous situation if the trunk is full.

Electrical: My car’s radio was going out and I took to Ford for a check while getting oil change. They said normal don’t worry about it. At this time I was still in warranty. When taken to Ford the 2nd time,they “reset” my SYNC & then the radio/touchscreen complete stopped working within 48 hours. When I told them, I just happened to be out of warranty then. Touch screen is completely blank! It will not turn on or allow controls for heat nor a/c. Cannot see backup camera nor can I hear the beeps. The USB plugs and outlets are also not working! This began in January 2020. I have a 7 month old at the time and it was a very cold winter. Engine: Fast forward to August 2020, my car just shut down in the middle of the highway and started shaking with my then 15 month old! Pulled over and had

My Engine is on my car will not go over 25 miles and if it does it shakes and I place the car in park or shut it off u can hear like water sound coming from the engine were it’s seems as if it was boiling

I heard fluid from what seemed like my dashboard and a puff of white smoke, no sensors came on. My Ford fusion continued but ran rough. I was pulling out of a parking lot onto the street and my Ford fusion was nearly t-boned because it would not accelerate. Later that day my overheat sensor came on and my fusion left me stranded on the side of the road in the middle of nowhere with a baby in 100 degree heat. I called a local mechanic, he put water in it and drove it to his shop. After 400 dollars worth of work the problem persistent, he then checked it for the notorious coolant intrusion issue and confirmed a misfire and coolant intrusion in cylinder 2. It's now parked and has not been driven in 3 months.

The contact owns a 2018 Ford Fusion. The contact stated during a routine oil change and tire rotation, the contact was informed that the lug nuts were swollen and needed to be cut off to be removed. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 58,000.

Went to have car serviced and was told lug nuts were swollen and it was a Ford defect, but had to pay over $120 to replace lug nuts in order to get my tires rotated.

Upon entering off ramp to highway , upon acceleration car shudders and goes into limp mode, can't accelerate and forced to try and pull over to stop vehicle and re-start. Very dangerous as it is random, can't re-create and has happened at highway speeds, very unsafe. Took it to dealer, Ford could not recreate and said there were no codes present and subsequently found nothing wrong.

Shift actuator wouldn’t go into gear I was stranded a few times had to be towed twice. I’ve found a plastic bushing that showed a $4.00 part could be responsible. Deadly for us disabled Vietnam veterans . I can’t walk. Maine has 200 vehicles with the same issues nationwide who knows supposedly the actuator will not be made by ford motors until February 2026. I’m 76 years old this is a hazard I can’t afford to buy another car. Please help us. Or get stranded in the middle of nowhere freezing cold Thank you

Rear seatbelt driver side seat belt does not click or buckle at all. Nothing is stuck in it and it has never buckled as long as I’ve had the car