2020 Ford Fusion owner complaints

In early October 2025, the vehicle was taken to an independent dealership service department for a routine oil change. Several weeks later, the vehicle appeared to be leaking fluid and began experiencing loud knocking/clacking noises, significant vibration, and drivability concerns, especially during acceleration. On October 10, 2025, while parked at a family member’s residence, the vehicle would not start. Due to safety concerns, the servicing dealership arranged for the vehicle to be towed for inspection. Technicians found a split transmission hose causing transmission fluid loss, which was repaired; however, the abnormal noises, vibration, and drivability issues persisted. Further inspection identified loud popping/clacking noises from the bell housing area. The technician physically

When these problems started it was only 6 months after purchase and I was already having issues with power train malfunctions and it didnt want to switch gears. I purchased this at roughly 47,000 miles and it didnt make it to 70,000 miles before I ultimately decided it was not the safe vehicle that was advertised to my family and I. It was taken to the dealership over 3 times in under a year and for some reason the problem never got resolved. I have been sued for the remaining balance now despite that toward the end of my time owning it the vehicle was reving out with barely any pressure on the gas pedal, having issues braking on its own (anti-collision assist), and occasionally the steering wheel would jerk me in to oncoming traffic. I am just trying to get a recall issued at this point b

My Ford started making a loud noise whenever the accelerator wasn't being pressed, after taking it to the mechanic, he said it is the cracked flex plate. After some light research, it was aparent that this is an issue that Ford's cars have, and ford has tried to make it better by offering free fixes. I contacted the local ford dealer and since the car has 90,000 miles, it would have been covered. However, since it doesn't have a clean title, I was declined this service free of charge. I don't agree with this decision since I've been driving this car for over a year since it was purchased off IAA auction, and this issue was made clear only yesterday, but this issue is prevalent in cars like mine.The damage to my car specifically was to the back, and only affected the rear bumper and trunk.

Car shifts into 1st gear when traveling at higher speeds (45+mph), causing a significant jerk and almost causing a rear end collision to myself. Car also loses power and jerks significantly hardwhen shifting to reverse and drive from Park. Afraid to travel over 45mph due to the downshifting.

The touchscreen display is not working. It turned completely black. I cannot change the radio station. I shut off my car and turned it back on and it is still not working had to hard reset the system car also shifts hard in and out of park and reverse, makes a clunking sound and shifts hard in first and second

The contact owns a 2020 Ford Fusion. The contact stated that the fuel door would randomly disconnect from the vehicle. While idling at a stop light, the vehicle shut off. The contact stated that while restarting the vehicle the vehicle jerked and hesitated while shifting gear before accelerating. The vehicle was taken to the dealer who was unable to determine the cause of the failure because there was no warning light illuminated. The fuel door had been replaced; however, the vehicle still experienced the failure with the START/STOP function. The contact stated that the failure became a persistent failure. The contact stated that approximately 6 to 8 months after the first failure, while driving approximately 35-45 MPH, the vehicle stalled. The contact used the App to restart the vehicle.

The flex plate is bad and ford won’t fix it. It needs recalled before it kills someone. Flex plate is the plate that puts power from engine to transmission

The contact owns a 2020 Ford Fusion. The contact stated that the gear shifter failed to shift into the intended gear and the vehicle would not drive forward. Upon inspection, it was discovered that transmission fluid had leaked from the vehicle. The vehicle was towed to the local dealer who diagnosed that the transmission had failed and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was 66,000.

The contact owns a 2020 Ford Fusion. The contact stated while driving at an undisclosed speed, the contact heard an abnormal knocking sound coming from the engine compartment. The vehicle was taken to the dealer and diagnosed with a failed flex plate and torque converter. The contact was informed that the flex plate and the torque converter needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 63,000.

I can hear the coolant sloshing around and gurgling while the vehicle is in park with the heat on. When I turn the heat off, the sloshing and gurgling goes away. It appears that I do not have a coolant leak.

The contact owns a 2020 Ford Fusion. The contact stated the vehicle was started and the check engine warning light illuminated. The contact had taken the vehicle to an independent mechanic where it was diagnosed and determined that there was coolant intrusion into cylinder #2, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not informed of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 68,000.

The contact owns a 2020 Ford Fusion. The contact stated that while operating the vehicle, there was a ticking and knocking sound coming from the engine compartment. The vehicle was taken to the local dealer. The cause of the issue was not yet determined. The manufacturer was not contacted. The failure mileage was 79,000.

There was a recall on 2020 Ford Fusions in 2022 on flex plate. My car miles at 90,000 and I started to hear the ticking noise. I did my research and I seen that it has the same noise that my car is making now. I called the dealership and the dealership said that I had no active recalls on my car and that the recall was specific to certain cars. Even though my car wasn’t apart of the specific VIN. I had a mechanic check it out and it was the flex plate. I’m still having issues with my flex plate but they want me to come out of pocket , I never had a engine light or anything come on I just started hearing this loud noise and it progressively has gotten worse.

If the car is parked in directly sunlight and I start the car a "Front camera temporarily unavailable" message will appear. It happens more when the outside temperature is warmer.

The alternator was producing too many volts, which would short circuit the battery and electrical components in the car. This would cause the car to lose power and not be able to accelerate. My car would randomly lose power on the highway, with no warning, resulting in my car suddenly slowing down. This was dangerous for the cars around me who are going 60+ and then my car quickly drops to 40 or less mph. In addition, to solve the issue I would have to pull off onto a shoulder to shut the car off and back on. This issue started around 3-4 yrs ago and has gotten worse as time passed. The problem was identified and resolved by Firestone when they ran a diagnostic. No check engine light was on in the car to alert me of any issues. I replaced both parts on the car.

Water is leaking into the trunk of our vehicle through the tail light assembly and soaking all the electrical wiring in the base of the trunk. The wheel well is becoming flooded with water. All the wiring going in and out of the trunk is soaking wet. If you Google this issue. Other Ford Fusion owners with older model vehicles and the same tail light assembly are having the exact same issue where water is coming into the trunk from the tail light assembly. This is clearly a design flaw and with water coming inside and covering the electrical system I want to believe this is major safety concern.

Finish on inside of wheels flacking off and rusting

My 2020 Ford Fusion has a broken shift bushing. Which is causing my dial box to revert back to park after changing gears.

The contact owns a 2020 Ford Fusion. The contact stated while driving at an undisclosed speed, the front passenger's side low beam headlight failed to illuminate as needed. Upon inspecting the vehicle, the contact noticed that the front passenger's side low beam headlight assembly wiring harness was burnt, and there was light smoke coming from the wiring harness. The vehicle was taken to the local dealer, where it was diagnosed that the low beam headlight assembly needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 53,000.

On hot days the Forward Collision will show as unavailable, but there is no notification saying when it will be available again. This is dangerous in that a safety feature on the vehicle is unavailable when it is hot outside and has been sitting in the sun. Outer door panel skins are becoming unattached from the door frame, which could cause an issue if the skin fails elsewhere that it would be totally unattached to the door frame and fall off when driving. The rear package tray trim (carpeted trim piece behind the rear seats covering the speakers) disintegrates when it is touched due to it being exposed to the sun. Discovered when attempting to clean inside of my rear window. This has caused black particulate to be scattered throughout the vehicles interior. They are small enough that y