TECHNICAL SERVICE BULLETIN: INFOTAINMENT SOFTWARE UPDATE PROCEDURE - This bulletin provides information on the process for downloading infotainment software updates and preparing USB for installation on applicable Kia vehicles. The software downloads and USB preparation process is similar across all supported platforms; however, in‑vehicle installation procedures vary by head unit type.
full bulletin at NHTSA ↗2020 Kia Stinger electrical problems
moderate 5 complaints filed with NHTSA · avg repair $850 · see electrical across all vehicles →
Complaints
5
Recalls
0
Avg fix
$850
When does it fail?
Of the 5 electrical complaints filed for the 2020 Kia Stinger, here's the actual mileage breakdown — failures cluster heaviest at 0-25,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering electrical on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
TECHNICAL SERVICE BULLETIN: AVN 5.0 WIDE NON-RESPONSIVE RADIO ICON (AM, FM, SXM) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to update the software on 5th Generation AVN wide on certain 2020-2024MY Kia vehicles (refer to model list on page 3) to remedy a 'non-responsive' or 'inoperative' radio (FM, AM, SXM, etc. ) concern. The affected AVN unit on the vehicles may not respond when pressing the 'RADIO' hard key/button on the AVN unit or when selecting the 'RADIO' icon on the AVN menu screen.
full bulletin at NHTSA ↗VOLUNTARY EMISSIONS SERVICE CAMPAIGN: THETA 2.0L T-GDI ECM SOFTWARE LOGIC IMPROVEMENT (SC279) - This bulletin provides information to upgrade the software logic of the engine control module (ECM) with an improved version on 2018-2021MY Stinger (CK) vehicles equipped with a Theta 2.0L T-GDI ULEV engine manufactured from September 29, 2017 through January 20, 2021. The subject vehicles may have engine calibrations that were not optimized for emissions standards under certain specific conditions, which may cause the vehicle to release air pollutants which exceed Federal and California standards (such as NMOG (Non-Methane Organic Gas) and CO (Carbon Monoxide) during IUVP (In-Use Verification Pro
full bulletin at NHTSA ↗VOLUNTARY EMISSIONS SERVICE CAMPAIGN: OWNER NOTIFICATION - This document is the owner notification advising that Kia is conducting a Voluntary Emissions Service Campaign on certain 2018-2021 MY Kia Stinger vehicles equipped with 2.0L Turbo GDI engines manufactured from September 29, 2017 to January 20, 2021 to improve the emissions logic in the Electronic Control Module (ECM) to ensure compliance with emissions regulations. This condition may cause the vehicle to release air pollutants that exceed Federal and California standards.
full bulletin at NHTSA ↗VOLUNTARY EMISSIONS SERVICE CAMPAIGN: DEALER PRINCIPAL MEMO - This document is the announcement to the dealer principals that Kia is conducting a Voluntary Emissions Service Campaign on certain 2018-2021 MY Kia Stinger vehicles equipped with 2.0L Turbo GDI engines manufactured from September 29, 2017 to January 20, 2021 to improve the emissions logic in the Electronic Control Module (ECM) to ensure compliance with emissions regulations. This condition may cause the vehicle to release air pollutants that exceed Federal and California standards.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 5 most recent
I was sitting at a red light with my foot on the brake. When I took my foot off the brake when the light turned green, my car would not drive forward!! I checked to make sure my car was not in Park. All of the lights on the dash were on and the engine was no longer running. Not to mention something similar happened November 18, 2023 where I was driving and the engine suddenly lost power And cut…
1st safety related incident discovered December 27th, 2021, rear window defroster stopped working. Checked rear fuse block as the owner's manual had listed that the fuse would be located there. Visual observation of fuse block showed rear heater fuse had blown and the area around the fuse discolored and melted. Remedy was dealership replacing rear fuse block and given back with no explanation…
Fuel line connection within the engine compartment had a lock/cover that was not seated/attached. Issue was discovered after doing a thorough look over of a newly purchased vehicle in which a loose nut was found in the trunk. Upon removal of the plastic engine cover next to the non locked fuel line two missing bolts were found for a wire harness on top of the engine. Owner connected fuel line…
The vehicle will shut off without reason from time to time. I'll be sitting at a light, stop sign, or intersection, and the car just shuts off. All electronics inside the car turn off, the engine turns off, and it's as if I've shut the car off to get out. Usually, I'm able to restart the car after a few moments and go about my day, but in doing some research on this issue, there have been…
I purchased this car brand new in july and have had the same electrical system problem at least 7 times now. The issue is that sometimes, when I give a right hand turn signal, the vehicle's entire electrical system shuts down. It has done it on a slow turn, on a merge going 35mph, and on a a highway exit ramp going 60mph. This is dangerous and only a matter of time until me, or someone else, dies…
Had electrical trouble with your 2020 Kia Stinger?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the electrical problem on the 2020 Kia Stinger?
It's a documented issue but not catastrophic. 5 complaints have been filed. Repairs average $850 and most owners catch it before it causes a breakdown.
At what mileage does the electrical typically fail?
Based on the 5 complaints filed, electrical issues most often appear around 25,336 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $850 for electrical repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to electrical?
No active recalls currently cover electrical issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2020/Kia/Stinger.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.