2021 Ford Bronco Sport owner complaints

The contact owns a 2021 Ford Bronco Sport. The contact stated that the vehicle was taken to a vehicle inspection station, and the contact was informed that the test could not be performed due to a faulty sensor. The contact was informed by a mechanic at the inspection station that the vehicle might be under recall. The local dealer was notified of the failure, and the contact was informed that the vehicle was not included in the recall. The contact was provided an estimate for the repair. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 32,000.

My daughter was operating the vehicle when it unexpectedly lost power and came to a stop without warning. The instrument panel began flashing, and she was unable to restart the vehicle to move it out of traffic. A jump-start was required to get the vehicle operational. It has been taken to Koons Ford Annapolis for evaluation. Vehicle mileage is aprox. 27,000

Vehicle experienced catastrophic power failure while I was driving. Without warning, the vehicle shut down completely. The engine stopped, the brakes engaged, the dash went black. There was no way to communicate with the vehicle -- no way to engage emergency flashers or even to push it to the side of the road (because the brakes were locked). There was a loud "pulse" sound coming through the speakers -- "thump. . .thump. . .thump. . ." which continued for 5 - 10 minutes. A police officer who stopped to assist noted the rear tail lights were strobing. The "P" on the transmission shifter flashed continually. Over the next 30 minutes, the infotainment screen rebooted twice, but went to black within seconds. The instrument panel rebooted once, but also went black after a few seconds. The car

Driving the vehicle between on a highway and, repeatedly, the control panel would completely shut down with the warning that the battery was running low on power. It doesn’t make sense since the vehicle is less than two years old.

The contact owns a 2021 Ford Bronco Sport. The contact stated that while driving at undisclosed speeds and while in reverse, the instrument panel occasionally flickered. The battery failure warning light illuminated intermittently. In addition, the contact stated that while attempting to start the vehicle, the engine failed to turn over. AAA was contacted and arrived on the scene to replace the battery. The local dealer was contacted; however, the vehicle was not diagnosed or repaired due to the cost. Upon further investigation, the contact related the failure to NHTSA Campaign Number: 24V267000 (Electrical System, Power Train); however, the VIN was not included. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage w

The contact owns a 2021 Ford Bronco Sport. The contact stated that when the vehicle was in reverse, there was a loud squealing sound coming from the rear end of the vehicle. There were no warning lights illuminated. The vehicle had been taken to the dealer six times to be diagnosed and the contact was informed that the rear brakes needed to be repaired. The gaskets and brake calibers were replaced; however, the failure reoccurred. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline to file a complaint. The approximate failure mileage was 5,000.

Our vehicle has multiple issues with it's brakes since we purchased the vehicle in December of 2021. Initially, when we would use our brakes while in reverse, the brakes would make a groaning sound (this started around January of 2022). We assumed it had something to do with the recall announced about the brakes of the vehicle and waited for parts to become available to get the brakes fixed. We finally got our brakes replaced once parts became available, but this did not fix the rear brake sound. The dealership replaced the rear brakes and the noise stopped. We brought the vehicle home and the front brakes began to squeal when using them while in drive. We called the dealership and let them know and they said to bring it back in. We brought the vehicle in, they replaced the front brakes an

The vehicle seems to have long stopping distances and I experienced shaking at highway speed. Also, when I back up, there is a very loud moaning noise, like a ‘ship horn’. This noise occurred several times from when I first bought the new vehicle and each time I took it to the dealer, they said they couldn’t duplicate the problem. That was over 4 times now that the dealer denied there was a problem. I then made a video of the noise to prove it to the dealer. They agreed there was a TSB for caliper pins and bushings, so they did that work. Before I left the dealer service department, the problem happened again to the Service Advisor, so they have the car now waiting for Ford to investigate. Online Ford Bronco forums also show a defect in the ‘coefficient of friction’ for the brake pa

The contact owns a 2021 Ford Bronco. The contact stated while reversing at approximately 3 MPH, the contact depressed the brake pedal and there was a loud honking sound inside the cabin on the passenger’s side of the vehicle. The contact stated that the noise was heard at start-up and while reversing and depressing the brake pedal. The contact stated no warning light was illuminated. The contact called a local dealer and was informed that the sound was not related to a recall. The vehicle was not repaired. The manufacturer had been contacted but the contact was transferred to the NHTSA Hotline. The failure mileage was 7,982.

The contact owns a 2021 Ford Bronco Sport. The contact received notifications of NHTSA Campaign Numbers: 25V019000 (Electrical System) and 25V467000 (Fuel System, Gasoline). The contact stated that while stopped at a traffic light, there was an abnormal sound coming from underneath the passenger-side of the vehicle, and the vehicle stalled. No warning lights were illuminated. The contact stated that approximately a minute later, the vehicle restarted independently. The contact stated that upon shifting to drive(D) and depressing the accelerator pedal, the vehicle failed to accelerate. The contact shifted to reverse(R), and the vehicle accelerated forward unintendedly. No warning lights were illuminated. The contact test-drove the vehicle in a parking lot, and the failure persisted. The con

The car caught fire the morning of Dec 11, 2024 while the vehicle's owner was driving their children to school. There are photos and a fire report is being generated. The vehicle's owner and her children could have been killed. Early indications are that the fire was caused by the same faulty engine/exhaust system defect that the owner has been complaining to Ford about for years. It is assumed the fire report will confirm that. For the past two or more years the vehicle has been emitting exhaust fumes into the passenger compartment of the vehicle while driving. This has caused the vehicle's owner and her children to get sick and forced them to drive the vehicle with the windows down at all times even in cold weather. Ford's dealers have confirmed the problem several times, but either coul

The contact owns a 2021 Ford Bronco Sport. The contact stated while driving at an undisclosed speed, the vehicle started losing motive power. A message advising a power train failure was displayed. The driver was able to exit the highway at 15 MPH. The vehicle was driven to a nearby dealer, where the computer was rebooted; however, the failure recurred several times while driving. The vehicle was taken back to the dealer several times, and the transmission was rebuilt. The contact stated that the failure had been recurring while driving. The contact stated while her husband was driving 70-80 MPH, the vehicle lost electrical power and stalled. The check engine and the power train warning lights were illuminated. The driver was able to pull to the side of the road. The vehicle was able to re

The windshield developed a crack down the center of the windshield starting at the top of the glass. There is no apparent indication that crack is due to an object hitting it.

The contact owns a 2021 Ford Bronco Sport. The contact stated while the vehicle was parked, the windshield washer fluid was leaking out of the front camera. The windshield fluid warning light was illuminated. The failure occurred on several occasions. The vehicle was towed to a dealer to be diagnosed; however, the dealer informed the contact that a cause for the failure was not found. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was unknown. The VIN was not available.

I bought my 2021 Ford Bronco at Morrie's Grand Ledge Ford. I live 10 minutes away from Morrie Ford Okemos. I received a recall notice from Ford Motor Company in August of this year regarding a recall of my specific vehicle. The issue is: "there is a possibility that a fuel injector may crack, which may result in fuel accumulating on the top of the engine. Liquid fuel and/or fuel vapor that accumulates near a hot surface, such as a hot engine or exhaust components may ignite resulting in an under-the-hood fire, increasing the risk of injury." I spoke to the Morrie's Okemos Ford Service Manager and was told "Ford Motor Company has not authorized this repair" and "there's nothing I can do about it." And, then he told me to call Ford Motor Company if I had a complaint. I am out of my mind fur

I have the same symptoms of recall 21V625000, they check my SUV however they said its not afected by the recall and the problem is still happening.

The contact owns a 2021 Ford Bronco Sport. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed, however, the vehicle failed to accelerate as intended. Additionally, the contact stated that the vehicle sputtered. The dealer was made aware of the failure. The vehicle was scheduled for a service appointment to have the recall repairs performed. The contact stated that when the vehicle was taken to the dealer, the contact was informed that the appointment needed to be rescheduled due to dealer scheduling. The contact received notification of NHTSA Campaign Numbers: 22V859000 (Fuel System, Gasoline) and 24V267000 (Electrical System, Power Train); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exce

The contact owns a 2021 Ford Bronco Sport. The contact stated that while driving with the high-beam headlights engaged, there was a dark spot on the driver's side headlight, reducing the visibility of the roadway. The contact stated that the failure was distracting. The vehicle was taken to the dealer, and the contact was informed the failure was caused by a design flaw. The dealer informed the contact that there was a piece of metal hanging inside the headlamp housing, which interfered with the driver's side headlight while driving. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA hotline for assistance. The failure mileage was approximately 17,000.

Torque converter failure at 100,000 miles. Car hesitates when it accelerates creating delay when going from stop to start.