2022 Ford Expedition owner complaints

Since purchasing this vehicle in January of 2023, it has been to the dealer three times to repair a failed blind spot monitoring system and rear cross traffic alert system due to corroded pins in the connectors of the sensors. According to the dealer, this is due to the connector utilizing only four of eight pins which leaves four pins unused and open to corrosion. On the third trip in, the dealer applied, "super glue" to try and prevent any future corrosion. While there was not a specific accident related to this, I do believe this has the potential to cause issues in the future if not properly addressed by Ford. See attached pdf from dealer for additional supporting information.

The contact owns a 2022 Ford Expedition. The contact stated that while her husband was having a light bulb replaced, the dealer became aware that the electrical wiring was damaged due to rodents chewing on the wiring insulation. The vehicle was repaired but the failure persisted. There was no warning light illuminated. The manufacturer was notified of the failure. The failure mileage was 22,489.

I just had the same issue described in the forum listed below. Extremely loud max volume screeching static through the speakers. Tried turning the car off and on several times, tried turning the radio off, tried switching to Serius xm radio, nothing would make it stop and it was completely unsafe to drive it like that. It was too loud to hear anything else over it and it was so jarring. I now have a headache and i’m nervous to drive it for fear of it happening again. My husband had to disconnect the battery to get it to stop. I have a video but it doesn’t seem like I can upload it here, only pics. https://www.f150gen14.com/forum/threads/extremely-loud-electrical-pop-followed-by-loud-static.9591/page-4

My vehicle doesn’t alert me of incoming vehicles and the reverse camera stays on. When I turn on my vehicle the dash stays on with ford sign so when I put on reverse my back up camera doesn’t turn on at all. I have to use all my mirrors to back out of parking. This feature hasn’t been working properly for a year. They keep telling me ford is working to fix this issue.

My employee was walking to his Ford 2022 Expedition, he had started it remotely, went to open the back of the vehicle, and the glass exploded. We have a video of it happening from a ring camera system.

I have a 2022 Ford Expedition that Ford states some of these are under recall for the backup camera but not mine. On 10/28/25, my backup camera went out with a blank blue sometimes black screen. I took it to Marler Ford where they gave me an estimate of $1000 to replace the camera. I received an oil change on the same day. When I got home I noticed from the diagnostics that my camera was loose in its setting and was able to easily remove it. I am assuming this occurred while at the dealership and will address this with them. While I contemplated what to do, I noticed a change 1 week ago when i backed up even though the camera was removed. It showed the back up lines and no longer the blank screen. I placed the camera back in and now it is working but is still loose so I removed it so it d

My speakers / sound system made a loud sound and minutes later my speakers were explosively loud. I couldn’t get the noise to stop. It was a static / gunfire at the highest volume. I turned my car in and off and couldn’t get it to turn off. It blew my ear drums out. Ultimately had to pull the amplifier fuse to get it to turn off. We have not had it inspected yet. We are taking it to the dealership tomorrow although I have heard of many issues of other owners having the same speaker problem. The only thing that happened before this incident. I thought it sounded like something fell inside my door or dash. I was in park when that happened and had just gotten into my car. Not five minutes later, the speakers blared. Thank god my kids were not in the car this time but I have an infant and he

Loud booming sound followed by loud crackling coming from speakers. Thought I was in an accident and slammed on the brakes. No one was behind me, but if there was, the person may not have been able to stop. Happened yesterday 10/2/2022 at Huber farms in Indiana at slow speed. Also happened on 9/12/2022 when stopped. Went to Bloomington Indiana community ford while it was still crackling. A service department staff came and did something and the crackling finally stopped. They could not diagnose the problem and returned the car to me on 9/15/2022.

The contact owns a 2022 Ford Expedition equipped with Hankook, Tire Line: Dynapro, Tire Size: 275/55/R20, DOT Number: (N/A). The contact stated that while the vehicle was parked, the contact became aware that the tire pressure was low. Additionally, the check engine warning light was illuminated. The contact drove to Discount Tire to inflate the tire. The contact stated that there was an abnormal sound coming from the brake pedal. The vehicle was taken to a dealer where it was diagnosed and determined that the battery needed to be replaced, and the brake pedal needed to be cleaned. The battery was replaced, and the brake pedal was cleaned. The vehicle was driven back to the dealer where it was diagnosed, and the failure was linked to the brake pads and rotors. The manufacturer was notified

Trailer brake controller is not engaging trailer brakes when the brake pedal is pressed. The trailer brakes will engage when manually squeezing the controller. Exact same symptoms as my 2021 f150 which had the recall. This is a September build, dealer service is telling me there is nothing wrong, it all checks out.

When slowing down to turn into a parking lot my car suddenly experienced sudden “phantom braking”. I was going slowly and I wasn’t braking. My car only has automatic braking when cruise control is on. Cruise wasn’t on. The car suddenly braked hard and chimed twice. My car has a collision warning system but that doesn’t chime like this. I didn’t see any dash warning lights, it looked normal by the time I looked for warning lights. I coasted into the parking lot because I wasn’t even sure if the engine was running. I couldn’t find anything wrong and everything has seemed normal since then. When it braked, I had my foot above the brake pedal because I was getting ready to brake further as I turned. When the phantom braking happened I felt the pedal move. It suddenly depressed then and sprung

Documentation of unwarranted / uncontrolled vehicle acceleration: driver stated that while vehicle was stopped in traffic, vehicle accelerated without use of accelerator pedal. Vehicle lurched forward into vehicle ahead, and into 2nd vehicle ahead in traffic. Engine continued to race at high speed with transmission in drive, spinning rear tires uncontrolled with both feet depressing brake pedal. Vehicle had to be put in neutral to shut off engine. Approximately 15 - 20 minutes prior to incident, vehicles cruise control disengaged without reason while driving @ 60 MPH on parkway. System re engaged without further issue on parkway. There was no displayed warning lights or messages prior to incident incident report filed with Ford corporate motor co. Case # .

General: While driving this rental vehicle over the span of three days, I noticed and confirmed over a dozen times that the vehicle's speed control would dramatically increase with NO driver input or actions. Specific: The vehicle's cruise control would be on and active, set at various speeds; 55, 60, 65, 70, 75 (long, straight road with varying speed limits). In different circumstances (sometimes when being overtaken by another vehicle, or cresting a hill or when beginning to climb a hill), the speed control, while set would immediately, with no driver input other than light steering INCREASE to 15-30 mph above the speed at which the cruise control was set. Over the period of three days of rental I was able to verify this behavior many times and I was able to capture a video that shows

When the vehicle starts, two error messages appear. The first one is "Pre-Collission Assist not available" and the second one is "Front camera fault - Service required". Due to these errors, I have no collission assist and cruise control does not work and cannot be enabled. I have taken it to the dealer 3 times (Since the summer) to be repaired and they have reloaded the software each time. This has not fixed the problem and they refuse to replace any hardware. They have stated that it is a software issue and that a fix will be forthcoming but they have no fix or timeframe as to when it will be fixed.

The contact owns a 2022 Ford Expedition. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the recall was initiated in July 2025, and parts were still not available. The contact stated that the recall repair was urgently needed because the contact travelled with her grandchildren inside the vehicle. In addition, the contact was stuck in another State because the contact was afraid to drive the vehicle due to the safety recall. The manufacturer was made aware of the concern. The contact had not experienced a failure.

The contact owns a 2022 Ford Expedition. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not available. The dealer was contacted, and the contact was informed that parts were not available. The contact stated that the recall notification was received shortly after the vehicle was purchased. The manufacturer was not made aware of the failure. The contact had not experienced a failure.

The contact owns a 2022 Ford Expedition. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the parts for the recall repair were not yet available. The contact called the local dealer and was informed that the manufacturer would mail another notice when parts were available. The contact stated that a year ago, while driving approximately 30 MPH, the vehicle stalled. The contact stated that there was no warning light illuminated during the failure. The contact was able to restart the vehicle. The dealer was contacted but the vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not informed of the failure. The failure mileage was

The contact owns a 2022 Ford Expedition. The contact stated while driving at various speeds, the infotainment screen went blank without warning. Occasionally the vehicle would inadvertently shut off once the screen went blank. The contact stated that the adaptive driving system feature would independently active, causing the vehicle to jerk out of the driving lane, and the contact would temporarily lose control of the vehicle. In addition, the contact stated that the vehicle would independently surge forward upon depression of the brake pedal without warning; while in reverse(R) or drive(D). The vehicle was taken to the dealer on multiple occasions however, the parts to repair the vehicle were on backorder. The contact filed a complaint with the manufacturer. The vehicle was not repaired.

The contact owns a 2022 Ford Expedition. The contact stated that while driving at approximately 45 MPH, a vehicle that was making a U-turn crashed into the rear passenger side door and that after the impact, all of the air bags failed to deploy. The contact's son, who was seated in the front passenger seat, had his seatbelt retractor failed to lock as a result he lunged forward from the impact and causing him to hit his chest against the instrument panel. Additionally, the contact stated that her other son was seated in the rear passenger seat and that after the impact, his seat belt was unlatched inadvertently and hit the window. No warning lights were illuminated. A police report was filed. The contact stated that her son, who was seated in the front passenger seat required medical atten

The contact owns a 2022 Ford Expedition. The contact stated while driving 40-80 MPH, there was an abnormal vibration in the vehicle. There was an abnormal humming sound coming from the vehicle. The vehicle was taken to the local dealer, where it was diagnosed and determined that the wheels, drive shaft, and u-joint needed to be replaced. The vehicle was repaired, but the failure persisted. The vehicle was taken to another local dealer, Bob Moore Ford (8948 S I-35 Service Rd., Oklahoma City, OK 73149); where it was diagnosed and determined that the tires and the rims needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and opened a case and referred the contact to the NHTSA Hotline. The failure mileage was approximately 400.