This Technical Service Bulletin sent to dealers addresses why the Mi-Pilot Assist/Adaptive Cruise stops working and provides guidance to collect and report diagnostic trouble codes.
full bulletin at NHTSA ↗2025 Mitsubishi Outlander electrical problems
severe 3 complaints filed with NHTSA · avg repair $850 · see electrical across all vehicles →
Complaints
3
Recalls
0
Avg fix
$850
1crash
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering electrical on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
This Technical Service Bulletin provides the re-start and cold start procedures for the A-IVI (Alliance In-Vehicle Infotainment) to avoid unnecessary unit replacements.
full bulletin at NHTSA ↗This is a Service Campaign bulletin sent to dealers providing direction to reconfigure the Body Control Module (BCM) to the appropriate settings.
full bulletin at NHTSA ↗This is a Technical Information Notice sent to dealers providing an overview of a service campaignto reconfigure the Body Control Module (BCM) to the appropriate settings.
full bulletin at NHTSA ↗This Revised Technical Service Bulletin provides instructions to reprogram the secondary speaker amplifier for the Yamaha Ultimate system.
full bulletin at NHTSA ↗Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 3 most recent
I rented this vehicle from Alamo/Enterprise at Denver Airport on 9/7/2025, and that day, while enroute to Casper WY hit a large deer on I-24 N in Wyoming where the posted speed limit is 80 mph, which was exactly the speed I was travelling. The deer was struck by the drivers side front of vehicle, causing extensive damage , loss of headlight and many small parts and electronic sensors as there…
I tried to do remote start on my car and it said that it had failed. I went out to the car to try to turn it on, and when I hit the unlock button, it would not unlock. I had to manually use the key to open the driver side door, where I was met with the instrument panel showing that the RPMs, the gas gauge, and the miles per hour were all maxed out and stuck on one another. I have an infant in his…
Vehicle trips the GFI on disconnect from charging. If vehicle finishes charging, no issue. If you pull the cable before completing full charge, trips the GFI. Have a Prius Hybrid using same charger and no issue. Have checked this with another Outlander and same issue. Unplugging it during charge cycle trips the GFI.
Had electrical trouble with your 2025 Mitsubishi Outlander?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the electrical problem on the 2025 Mitsubishi Outlander?
It's a meaningful issue. 3 complaints have been filed and the failure mode causes operational problems for owners. Repairs average $850.
At what mileage does the electrical typically fail?
Mileage data is limited for this issue. Owners report failures across a wide range, suggesting cause is more about driving conditions and maintenance than mileage alone.
What does it cost to fix?
Independent shops typically charge around $850 for electrical repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to electrical?
No active recalls currently cover electrical issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2025/Mitsubishi/Outlander.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.