FORD: WATER LEAKS, WIND NOISE AND/OR NOISE ON OPENING/CLOSING THE MOON ROOF/ROOF OPENING PANEL. THE 2004-07 WSM MANUAL PROVIDES TWO SEPARATE PROCEDURES FOR MOON ROOF HEIGHT A HORIZONTAL ADJUSTMENTS. HEIGHT AND HORIZONTAL PROCEDURES NEED TO DONE TOGETHER. MANUAL PROCEDURES IS IN THE PROCESS OF BEING UPDATED.
full bulletin at NHTSA ↗2008 Ford Expedition visibility problems
severe 8 complaints filed with NHTSA · avg repair $350 · see visibility across all vehicles →
Complaints
8
Recalls
0
Avg fix
$350
1crash
When does it fail?
Of the 8 visibility complaints filed for the 2008 Ford Expedition, here's the actual mileage breakdown — failures cluster heaviest at 25,000-50,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
What stands out
No new NHTSA visibility complaint has been filed on this vehicle in over 15 years — the issue may be aging out of the active population.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering visibility on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 4 most recent
While my wife was rolling up the passenger side window in our vehicle, the window became stuck and would not roll back up. Now my wife and two kids were stuck riding around with a widow halfway rolled down in cold weather. She took the vehicle to the dealership and they wanted close to 400$ to repair it. This is pretty bad considering there is thousands of complaints on the internet on this same…
Tl* the contact owns a 2008 Ford expedition. During inclement weather the drivers side window will not roll down. However, the other windows in the vehicle work. The current mileage was 35,800. The vehicle identification number was unavailable.
My 2008 Ford expedition passenger front side window started a high pitch squeak/squeal when going up and down (power windows)a week later my driver front side window started the same, they both did this for about a month and then one morning I put the driver side down and went to put it up it started to shimmy up and down like it wanted to go up but would then go down again, after playing with it…
Tl* the contact owns a 2008 Ford expedition. The contact stated that while driving 65 MPH, he heard a loud explosion. After inspecting the vehicle he found that the rear lift gate glass imploded into the vehicle. The vehicle was not taken to the dealer. The manufacturer was made aware of the failure who did not offer any assistance. The vehicle was repaired. The failure and the current mileage…
Had visibility trouble with your 2008 Ford Expedition?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the visibility problem on the 2008 Ford Expedition?
It's a meaningful issue. 8 complaints have been filed and the failure mode causes operational problems for owners. Repairs average $350.
At what mileage does the visibility typically fail?
Based on the 8 complaints filed, visibility issues most often appear around 93,060 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $350 for visibility repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to visibility?
No active recalls currently cover visibility issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2008/Ford/Expedition.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.