On vehicles equipped with an automatic transmission it is imperative that the converter pilot hub be greased with Motorcraft Multi-Purpose Grease Spray XL-5-A even if grease was not applied from the factory. Also verify that the engine/transmission alignment dowel pins are present as well as the engine crankshaft dowel pin, if equipped, when installing the transmission. Failure to adequately lubricate the converter hub greatly increases the likelihood of the flexplate cracking in the future. Missing dowels may cause a misalignment issue also resulting in a premature failure. Refer to Workshop Manual (WSM), Section 307-01.
full bulletin at NHTSA ↗2011 Ford Ranger powertrain problems
moderate Owners of the 2011 Ford Ranger have filed 5 NHTSA complaints about the powertrain at roughly $2,500 to repair (U.S. federal records, as of August 2026). Source: NHTSA Office of Defects Investigation. See powertrain across all vehicles →
Complaints
5
Recalls
0
Avg fix
$2,500
| Model year | powertrain complaints |
|---|---|
| 2009 Ranger | 3 |
| 2011 Ranger (this page) | 5 |
When does it fail?
Of the 5 powertrain complaints filed for the 2011 Ford Ranger, here's the actual mileage breakdown — failures cluster heaviest at 25,000-50,000 mi.
0-25k
25-50k
50-75k
75-100k
100-125k
125-150k
150k+
Each bar shows the share of total complaints filed at that mileage range. Peak failure window highlighted. Some owners report problems earlier; some make it well past 150,000 miles symptom-free. Maintenance habits and driving conditions shift the curve as much as mileage alone.
What stands out
Among the 5 model years of Ford Ranger in our records for powertrain problems, this one ranks #3 by owner-complaint volume.
No new NHTSA powertrain complaint has been filed on this vehicle in over 9 years — the issue may be aging out of the active population.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering powertrain on this vehicle — documented repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall (it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting 1 most recent
Truck shifter is sticking, the antilock light trouble light comes on and truck will not shift from park. My son who is a mechanic says the brake switch is bad, you have to step on brake and wait for a click then the vehicle will shift into gear. So I tried this and indeed is the issue. This truck only has 40k miles on it. Problem started at about 30k miles I did not know that the issue was a…
Had powertrain trouble with your 2011 Ford Ranger?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the powertrain problem on the 2011 Ford Ranger?
It's a documented issue but not catastrophic. 5 complaints have been filed. Repairs average $2,500 and most owners catch it before it causes a breakdown.
At what mileage does the powertrain typically fail?
Based on the 5 complaints filed, powertrain issues most often appear around 38,864 miles. Some report problems earlier; some make it well past 150,000 with no symptoms. Maintenance habits matter — vehicles that received timely fluid services and were not regularly overworked tend to last longer.
What does it cost to fix?
Independent shops typically charge around $2,500 for powertrain repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to powertrain?
No active recalls currently cover powertrain issues on this vehicle. The complaints filed represent owner-reported failures that haven't risen to the level of a manufacturer-issued recall — but they're still worth knowing about before you buy or budget for repairs.
Related
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2011/Ford/Ranger.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.