2020 ford Explorer recalls

Every active NHTSA recall campaign for this vehicle, ranked by severity. Each entry shows the consequence if left unfixed and the manufacturer's prescribed remedy.

Critical

Severe

Moderate

severe NHTSA 19V687000 30/09/2019

Ford Motor Company (Ford) is recalling certain 2020 Ford Explorer vehicles equipped with 2

The A/C pulley may rub through the wiring harness insulation and contact the unfused battery positive wire, resulting in a short circuit, increasing the risk of a fire.

Fix: Ford will notify owners, and dealers will install a tie strap to the wiring harness at the hand shock tower clip, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S32.

severe NHTSA 20V730000 24/11/2020

Ford Motor Company (Ford) is recalling certain 2020 Explorer vehicles equipped with 2

An incomplete weld securing the inlet check valve to the fuel tank shell could result in a substantial fuel leak during a crash, increasing the risk of fire.

Fix: Ford will notify owners, and dealers will replace the fuel tank shell, free of charge. The recall began December 8, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S68.

severe NHTSA 20V497000 21/08/2020

Ford Motor Company (Ford) is recalling certain 2020 Explorer and 2020 Lincoln Aviator vehicles

If the side air bag or seat back fasteners were not properly tightened, the side air bag deployment could be affected, increasing the risk of injury during a crash.

Fix: Ford will notify owners, and dealers will remove front seat back panels from one or both front seats (VIN-specific) and verify that the fasteners have been properly tightened, free of charge. The recall began September 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S48.

severe NHTSA 20V693000 10/11/2020

Ford Motor Company (Ford) is recalling certain 2020 Explorer and Lincoln Aviator vehicles equipped with a 2

Defective drive shafts may fail and cause a loss of connection between the transfer case and rear axle, possibly resulting in a vehicle rollaway when in Park or a loss of drive. Either condition can increase the risk of a crash. The drive shafts can also deform and separate from the driveline and potentially contact the fuel tank, increasing the risk of fuel leaks and/or fire.

Fix: Ford will notify owners, and dealers will inspect the drive shaft label inspected and replace it as necessary, free of charge. The recall began December 11, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S65.

severe NHTSA 20V549000 10/09/2020

Ford Motor Company (Ford) is recalling certain 2020 Explorer vehicles

Vehicles with seat belt buckles that are not properly secured may fail to restrain an occupant during a crash, increasing the risk of injury.

Fix: Ford will notify owners, and dealers will replace the second row center seat assembly, free of charge. The recall began November 6, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S50.

severe NHTSA 21V154000 10/03/2021

Ford Motor Company (Ford) is recalling certain 2020 Lincoln Aviator and Ford Explorer vehicles

Broken RLCA bolts can cause a loss of steering control, and increase the risk of a crash.

Fix: Ford will notify owners, and dealers will replace both RLCA bolts, free of charge. The recall began on April 2, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S11.

severe NHTSA 24V188000 08/03/2024

Ford Motor Company (Ford) is recalling certain 2020 Explorer vehicles

A rearview camera that displays a blank or distorted image can reduce the drivers view of what is behind the vehicle, increasing the risk of a crash.

Fix: Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed April 4, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19. This recall is an expansion of NHTSA recall numbers 20V-575 and 22V-252.

severe NHTSA 19V575000 05/08/2019

Ford Motor Company (Ford) is recalling certain 2020 Explorer and Lincoln Aviator vehicles

Without the cover, the MPR lever may be unintentionally moved, allowing the vehicle to roll away. Being in Factory Mode, the vehicle will not display warnings and/or gear selection on the instrument cluster. Both conditions increase the risk of a crash.

Fix: Ford will notify owners, and dealers will inspect and, if necessary, install a MPR cover. Dealers will verify the instrument cluster is not in Factory Mode and clear any fault codes, free of charge. The recall began August 23, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C06.

severe NHTSA 19V859000 04/12/2019

Ford Motor Company (Ford) is recalling certain 2020 Explorer and Lincoln Aviator vehicles

A fuel leak in the presence of an ignition source increases the risk of a fire.

Fix: Ford will notify owners, and dealers will install a longer protective sleeve on the liquid fuel line, as necessary, free of charge. Ford issued owners and interim notification on January 29, 2020. Recall began March 23, 2020. A second notice will be sent once parts are available, expected to be late in the first quarter of 2020. A renotification letter was sent on July 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S49.

← Back to 2020 ford Explorer overview

Recall data sourced from the NHTSA recallsByVehicle public API. Campaign numbers, consequences, and remedies are reproduced from the official record. Manufacturers are required to provide the remedy free of charge for safety recalls — contact your nearest dealer with the campaign number to schedule the repair.