Free. Instant. No signup. Pulls recalls and complaints for your exact vehicle.
Couldn't find that VIN. Check the digits and try again.
2022 GMC Yukon fuel system problems
moderate
Owners of the 2022 GMC Yukon have filed 3 NHTSA complaints about the fuel system at roughly $1,200 to repair (U.S. federal records, as of September 2026). Source: NHTSA Office of Defects Investigation.See fuel system across all vehicles →
General Motors, LLC (GM) is recalling certain 2021 Cadillac Escalade, 2021, 2023-2024 Chevrolet Tahoe, and 2022 and 2024 GMC Yukon vehicles equipped with a 6-cylinder diesel engine
A fuel leak in the presence of an ignition source increases the risk of a vehicle fire.
Fix: Dealers will inspect for the correct fuel tank and replace it, if necessary, free of charge. Owner notification letters were mailed November 5, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252512770. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 18, 2025.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering fuel system on this vehicle — documented
repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall
(it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Service Bulletin22-NA-057Mar 2024
This technical bulletin provides a procedure replace the tappet that is located on the fuel door.
This Preliminary information communicates that when removing the fuel line jumper hose care should be taken to be sure the line is reinstalled correctly to avoid a no/low fuel pressure situation.
Emission Recall - General Motors has decided to conduct a Voluntary Emission Recall on certain vehicles. During servicing of these vehicles, an incorrect catalytic converter part that may not meet all emission system requirements may have been installed. Dealers are to replace the catalytic converter.
Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting
2 most recent
fuel system
· filed 09/22/2025
The contact owns a 2022 GMC Yukon. The contact stated that while attempting to start the vehicle, the engine failed to crank or start-up. After several attempts, the vehicle failed to start. The check engine warning light was illuminated. The vehicle was towed to the dealer, where it was diagnosed that the fuel pump power control module had failed and needed to replaced. The vehicle was repaired.…
fuel system
· filed 09/04/2026
The contact owns a 2022 GMC Yukon. The contact stated that while attempting to make a left turn at an intersection, the vehicle lost automotive power while the accelerator pedal was depressed. The vehicle was towed to a local Firestone, where the fuel pump module was replaced. The local dealer was contacted. Upon further investigation, the contact associated the failure with GMC Emission Recall:…
Had fuel system trouble with your 2022 GMC Yukon?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the fuel system problem on the 2022 GMC Yukon?
It's a documented issue but not catastrophic. 3 complaints have been filed. Repairs average $1,200 and most owners catch it before it causes a breakdown.
At what mileage does the fuel system typically fail?
Mileage data is limited for this issue. Owners report failures across a wide range, suggesting cause is more about driving conditions and maintenance than mileage alone.
What does it cost to fix?
Independent shops typically charge around $1,200 for fuel system repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to fuel system?
Yes — 1 active recall(s) cover fuel system issues on this vehicle. Recall fixes are always free regardless of mileage or warranty status. Use the VIN decoder at the top of the page to check if your specific vehicle is affected.
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2022/GMC/Yukon.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.