Free. Instant. No signup. Pulls recalls and complaints for your exact vehicle.
Couldn't find that VIN. Check the digits and try again.
2023 Ford Explorer suspension problems
severe
Owners of the 2023 Ford Explorer have filed 8 NHTSA complaints about the suspension at roughly $900 to repair (U.S. federal records, as of July 2026). Source: NHTSA Office of Defects Investigation.See suspension across all vehicles →
Complaints
8
Recalls
1
Avg fix
$900
suspension complaints on the Ford Explorer, by model year
Ford Motor Company (Ford) is recalling certain 2023 Explorer vehicles
A loose or missing connection between the knuckle and strut can cause improper tire alignment, resulting in a steering pull or require increased steering effort. Additionally, the brake hose may contact the tire and become damaged, resulting in a brake fluid leak and a loss of braking ability. Either of these scenarios can increase the risk of a crash.
Fix: Dealers will inspect the fasteners, and tighten or install them as necessary, free of charge. Owner notification letters were mailed March 08, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S04.
Is there a fix? Manufacturer service bulletins
The manufacturer has issued service bulletins covering suspension on this vehicle — documented
repair instructions, service campaigns, or warranty extensions sent to dealers. A TSB isn't a recall
(it's not a free safety remedy), but it's the manufacturer acknowledging the issue and how to fix it.
Service BulletinTSB 26-2242May 2026
This bulletin supersedes 25-2213. Reason for update: update the Service Procedure to add notes to clarify the customer symptoms, applicability of this TSB, directing technicians to evaluate both front strut mounts, and add Figure 1 to identify the specific area of the strut mount to observe. Some of the vehicles listed in the Model statement above may exhibit a click/pop noise while turning the steering wheel from straight ahead to full lock during low speed turning events. This noise may be due to the front upper strut mount washer movement under steering loads.
Some 2023 Explorer vehicles built on 01-Dec-2022 and through 31-Aug-2023 may exhibit a rattle/clunk/knock/pop/thump noise from the front suspension at low speeds between 8-20 mph (13-32 km/h) over bumpy or uneven pavement. This may be due a loose pressure tube within the strut assembly. Diagnose and replace the 18124 front strut or struts as needed by which side(s) the noise is isolated to. If noise persists, follow the Workshop Manual (WSM) > Section 204-00 > Diagnosis and Testing > Suspension System > Stop/Steer/Ride > Noise > Front > Over Bump. For claiming, use causal part 18124 and applicable labor operations in Section 3 of the Service Labor Time Standards (SLTS) Manual.
Source: NHTSA manufacturer communications. Bring the bulletin number to your dealer or shop.
What owners are reporting
0 most recent
Had suspension trouble with your 2023 Ford Explorer?
File a complaint with NHTSA → It's free, official, and how every report above got here — owner filings are the federal safety record this page is built on.
Common questions
How serious is the suspension problem on the 2023 Ford Explorer?
It's a meaningful issue. 8 complaints have been filed and the failure mode causes operational problems for owners. Repairs average $900.
At what mileage does the suspension typically fail?
Mileage data is limited for this issue. Owners report failures across a wide range, suggesting cause is more about driving conditions and maintenance than mileage alone.
What does it cost to fix?
Independent shops typically charge around $900 for suspension repairs on this vehicle. Dealer pricing tends to run 20-40% higher. The exact figure depends on the specific failure mode, parts availability, and your local labor rates. If you're outside factory warranty, an extended service contract often covers this category.
Are there any recalls related to suspension?
Yes — 1 active recall(s) cover suspension issues on this vehicle. Recall fixes are always free regardless of mileage or warranty status. Use the VIN decoder at the top of the page to check if your specific vehicle is affected.
Complaint and recall data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database. Verify the raw federal record at
nhtsa.gov/vehicle/2023/Ford/Explorer.
Severity ratings are derived from reported crashes, fires, injuries, and fatalities. Repair cost estimates are
independent-shop national averages and may differ in your area. Some links on this page are affiliate links.