The 2015 Ford Fusion has 1,061 NHTSA owner complaints and 13 recalls on file (U.S. federal records, as of September 2026). The most-reported system is engine at 245 complaints (~$3,100 to repair). Source: NHTSA Office of Defects Investigation.
Below average for the segment. Multiple systems have recurring complaints.
0
Critical
13
Severe
0
Moderate
Should you avoid this 2015 Fusion?
High-risk ownership
Repair exposure runs above average — only with money set aside and eyes open.
Brakes: 109 complaints, classified severe
Electrical system: 91 complaints, classified severe
Reliability score 4.0/10 — below the segment average
13 recall campaigns on file
Our read of the federal NHTSA complaint and recall record for this exact year and model —
not a substitute for a pre-purchase inspection. How we score.
NHTSA crash-test safety ratings
5 / 5 overall
Overall★★★★★5/5
Frontal crash★★★★★5/5
Side crash★★★★★4/5
Rollover★★★★★4/5
Driver-assist features on the tested model:
Electronic stability control: Standard · Forward collision warning: Optional · Lane departure warning: Optional
Source: NHTSA New Car Assessment Program — tested configuration: 2015 Ford Fusion 4 DR FWD. Stars rate crash protection in NHTSA's tests, not overall reliability — see the owner-complaint data below for what actually goes wrong.
Buying a used 2015 Ford Fusion? Check these first
Here's what this model is known to do — so you can inspect for it, price it in, or
make the seller fix it before you sign.
What to inspect on this specific car
engine — 245 owner reports
· ~$3,100 to fix
steering — 181 owner reports
· ~$700 to fix
powertrain — 140 owner reports
· ~$2,500 to fix
brakes — 109 owner reports
· ~$450 to fix
⚠ The one to take seriously: brakes is flagged
severe on this model
.
Inspect it closely on a test drive.
Recalls to confirm are done
Run the VIN from the listing — 13 active recalls on this model. Recall repairs are always free.
Verdict for buyers: 4.0/10 model. The priciest documented failure is
engine (~$3,100) — get the
seller's service records for it or inspect closely. Otherwise an average-risk used buy at a fair price.
We tell you what this model is known for and what to inspect — a vehicle-history report
tells you what this exact car has been through. Smart buyers get both.
A noise, a warning light, a repair quote, "should I buy this?" — get an answer grounded in
this vehicle's actual NHTSA record, not generic advice.
Dash light, leak, worn part — snap it and we'll read it against this car's record.
Photo attached — type a question or just hit Ask.
Answers use this vehicle's NHTSA complaint & recall record — owner-reported and unverified, not a diagnosis. Verify anything safety-critical with a mechanic.
Embed this reliability snapshot
Free to use on your site, post, or video — just keep the "Source" credit line below the chart. Preview the widget →
What owners are saying
recent NHTSA-filed complaints · verbatim
2015 Fusion· visibility
Driver side sun visor fell off hinge and was dangling from wire that powers vanity mirror. Plastic part holding it up seems to have fallen off. No screws there. Had to hold it in one hand until I could pull over and figure out how to stow it.
Tl* the contact owns a 2015 Ford fusion. While driving 25 MPH, the driver's side brake line malfunctioned. The brake pedal was very loose and traveled to the floorboard. The contact was able to pull into a parking lot and bump against a curb to stop the vehicle. The vehicle was…
Tl* the contact owns a 2015 Ford fusion hybrid. When the contact depressed the brake pedal to shift from park into drive to start the ignition, she was unable to shift gears and "parking gauge engaged" appeared. The contact also heard an abnormal noise coming from the vehicle.…
Had a problem with your 2015 Ford Fusion?
File a complaint with NHTSA → It's free and official — owner filings are what build the federal safety record behind this page.
Estimate your repair exposure
Drag to your current mileage. Numbers are derived from this vehicle's complaint history.
Ford Motor Company (Ford) is recalling certain 2015-2018 Focus and 2013-2016 Fusion vehicles previously repaired incorrectly under recall numbers 18V169 and 18V845
A transmission fluid leak in the presence of an ignition source such as hot engine or exhaust components can increase the risk of a fire.
Fix: Dealers will update the software, free of charge. Additionally, dealers will inspect Focus vehicles and replace the clutch assembly as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 5, 2026. Additional letters will be sent once the remedy is available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S43. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6,2026.
Ford Motor Company (Ford) is recalling certain 2013-2018 Fusion and Lincoln MKZ vehicles
A brake fluid leak will increase brake pedal travel and extend the distance needed to stop the vehicle, increasing the risk of a crash.
Fix: Dealers will replace the front brake hoses, free of charge. Owner notification letters were mailed June 27, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S12.
Ford Motor Company (Ford) is recalling certain 2013-2019 Escape, 2013-2018 C-Max, 2013-2016 Fusion, 2013-2021 Transit Connect, and 2015-2018 Edge vehicles
A damaged or missing bushing may prevent the vehicle from shifting into the intended gear, and cause the vehicle to move in an unexpected direction. Additionally, the vehicle may roll after the driver selects the 'Park' position. Either scenario increases the risk of a crash or injury.
Fix: Dealers will replace the under hood shift bushing and add a protective cap over the shift cable bushing, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed July 1, 2022. Remedy parts are expected to be available in 4th Quarter 2022. Owner notification letters were mailed October 27, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S43.
It's got known weak points. With a reliability score of 4.0 out of 10 based on 1,061 owner complaints filed with NHTSA, the 2015 Ford Fusion has a higher-than-average rate of reported issues. The areas to watch are listed above. Whether it's worth owning depends on price, condition, and how much repair exposure you can absorb.
Should you avoid the 2015 Ford Fusion?
The 2015 Ford Fusion is a higher-risk ownership prospect. Repair exposure runs above average — only with money set aside and eyes open. The record behind that call: Brakes: 109 complaints, classified severe; Electrical system: 91 complaints, classified severe; Reliability score 4.0/10 — below the segment average; 13 recall campaigns on file. This is our read of the federal complaint and recall data — not a substitute for a pre-purchase inspection.
What should I check before buying a used 2015 Ford Fusion?
Inspect the engine first — it's the most-reported issue on this model, with 245 owner complaints filed. Average repair cost runs about $3,100 at an independent shop. Also confirm any open recalls have been completed by running the VIN, and ask for service records covering the problem areas listed above.
Is the 2015 Ford Fusion a good used car to buy?
It scores 4.0 out of 10 on our NHTSA-based read of 1,061 owner complaints. The main thing to watch is engine. Priced fairly and clean on inspection, it's a reasonable used buy. Our data covers what this model is known for — pair it with a vehicle-history report on the VIN to see what that specific car has been through.
What's the most common problem on the 2015 Ford Fusion?
Based on NHTSA records, the most-reported issue is engine, with 245 complaints filed. Average repair cost runs about $3,100 at an independent shop.
What's the most expensive thing that goes wrong?
The engine is one of the costlier repair items. Average repair cost runs about $3,100 at an independent shop. Catching early warning signs can sometimes extend life by 20–30,000 miles.
How do I check if my Ford Fusion has open recalls?
Paste your VIN into the decoder at the top of this page. We pull live from NHTSA, so you'll see exactly which campaigns apply to your vehicle and whether the dealer has logged the fix. Recall repairs are always free regardless of mileage or warranty status.
Is an extended warranty worth it on a 2015 Ford Fusion?
Math is straightforward: a quality service contract runs $1,800–3,500 over 3 years. With 1,061 complaints on file and the costliest repair averaging $3,100, one major failure more than pays for it. The catch is reading the contract — many providers exclude wear items and require pre-authorization, so cheaper plans are not always better value.
Recall and complaint data sourced from the National Highway Traffic Safety Administration (NHTSA)
public records database, last synced 6 hours ago. Verify the raw federal record at
nhtsa.gov/vehicle/2015/Ford/Fusion.
Editorial commentary written by ProblemsByVin contributors and reviewed by ASE-certified mechanics.
We are not affiliated with Ford. Some links on this page are affiliate links and we
may earn a commission if you purchase through them.
